纳米零价铁协同硫酸盐对低浓度低有机质剩余污泥水解酸化性能的影响

金宝丹; 李霞; 覃贺鲜; 王冉; 王兰; 赵建国; 钮劲涛

doi:10.12187/2022.01.015

纳米零价铁协同硫酸盐对低浓度低有机质剩余污泥水解酸化性能的影响

1. 郑州轻工业大学材料与化学工程学院, 河南郑州 450001;
2. 河北地质大学华信学院资源与环境系, 河北石家庄 050700;
3. 河南恒安环保科技有限公司, 河南郑州 450001

作者简介: 金宝丹(1985-),女,吉林省农安县人,郑州轻工业大学讲师,博士,主要研究方向为污泥减量及资源化利用。E-mail:2016024@zzuli.edu.cn;

基金项目: 国家自然科学基金项目（42007340）
中图分类号: X703

Effect of nanoscale zero-valent iron cooperating with sulphate on hydrolytic acidification performance of excess sludge with low concentration and low organic matter

1. College of Material and Chemical Engineering, Zhengzhou University of Light Industry, Zhengzhou 450001, China;
2. Department of Resources and Environment, Huaxin College of Hebei GEO University, Shijiazhuang 050700, China;
3. He'nan Heng'an Environmental Protection Technology Co., Ltd., Zhengzhou 450001, China
Received Date: 2021-03-23
Accepted Date: 2021-07-07

CLC number: X703

摘要: 将低质量浓度低有机质剩余污泥在不同条件（自然条件、纳米零价铁（nZVI）、单过硫酸氢钾（PMS）、K₂SO₄、nZVI+PMS、nZVI+K₂SO₄）下进行发酵处理，通过分析发酵过程中溶解性蛋白质、多糖和挥发性脂肪酸（SCFAs）质量浓度、生物酶活性等指标，研究nZVI对污泥在不同硫酸盐条件下水解酸化性能的影响。结果表明，nZVI+PMS发酵系统水解酸化性能最强，蛋白质、多糖和SCFAs的质量浓度（以化学需氧量（COD）计）分别为255.07 mg/L、138.31 mg/L和356.8 mg/L；nZVI+PMS发酵系统蛋白酶和α-葡萄糖苷酶活性最强，但是nZVI发酵系统碱性磷酸酶和酸性磷酸酶活性最高，而K₂SO₄发酵系统生物酶活性与自然系统相似，可见nZVI能够有效提高PMS作用下的低浓度低有机质剩余污泥厌氧发酵性能。
- 厌氧发酵 /
- 纳米零价铁 /
- 硫酸盐 /
- 水解酸化 /
- 生物酶活性
Abstract: The waste activated sludge with low concentration and low organic matter was fermented under different conditions including natural, nanoscale zero-valent iron (nZVI), 2KHSO₅·KHSO₄·K₂SO₄(PMS), K₂SO₄, nZVI+PMS and nZVI+K₂SO₄. The soluble protein, polysaccharide, short volatile fatty acids (SCFAs) and biological enzyme were analyzed during the fermentation process, and the effects of nZVI on hydrolytic acidification performance of the excess sludge were studied. The results showed that hydrolytic acidification performance of the nZVI+PMS fermentation system was optimal, and the mass concentration of protein, polysaccharide and SCFAs was 255.07 mg/L, 138.31 mg/L and 356.8 mg/L respectively. The maximal activity of protease and α-glucosidase appeared in the nZVI+PMS fermentation system, however the maximal activity of alkaline phosphatase and acid phosphatase appeared in the nZVI fermentation system. In addition, the bioenzyme activity of the K₂SO₄ fermentation system was similar to that of natural fermentation system. These results indicated that nZVI could improve effectively the fermentation performance of the waste activated sludge with low concentration and low organic matter under PMS condition.
- anaerobic fermentation /
- nanoscale zero-valent iron /
- sulphate /
- hydrolytic acidification /
- biological enzyme
1. [1]
  YUAN Y, WANG S Y, LIU Y, et al.Long-term effect of pH on short-chain fatty acids accumulation and microbial community in sludge fermentation systems[J].Bioresource Technology, 2015, 197:56-63.
2. [2]
  任南琪, 王爱杰.厌氧处理构筑物中SRB的生态学[J].哈尔滨建筑大学学报, 2001(1):39-44.
3. [3]
  JAN W J, EELCO A A, GABRIELLE T, et al.Optimisation of sulphate reduction in a methanol-fed thermophilic bioreactor[J].Water Research, 2002, 36(7):1825-1833.
4. [4]
  WEI J, HAO X D, MARK C M X, et al.Feasibi-lity analysis of anaerobic digestion of excess sludge enhanced by iron:A review[J].Renewable and Sustainable Energy Reviews, 2018, 89:16-26.
5. [5]
  ZHOU J, YOU X G, NIU B W, et al.Enhancement of methanogenic activity in anaerobic digestion of high solids sludge by nano zero-valent iron[J].Science of the Total Environment, 2019, 703:135532.
6. [6]
  LI X M, ZHAO J W, WANG D B, et al.An efficient and green pretreatment to stimulate short-chain fatty acids production from waste activated sludge anaerobic fermentation using free nitrous acid[J].Chemosphere, 2016, 144:160-167.
7. [7]
  陈同斌, 李艳霞, 罗维, 等.中国城市污泥有机质及养分含量与土地利用[J].生态学报, 2003, 11:2463-2474.
8. [8]
  LIAO X C, LI H.Biogas production from low-organic-content sludge using a high-solids anaerobic digester with improved agitation[J].Applied Energy, 2015, 148:252-259.
9. [9]
  刘常青, 王玉兰, 林鸿, 等.低有机质污泥投加药剂联合低温热水解及后续厌氧发酵研究[J].化工学报, 2017, 68(4):1608-1613.
10. [10]
  XU Y, ZHENH L K, GENG H, et al.Enhancing acidogenic fermentation of waste activated sludge via isoelectric-point pretreatment:Insights from physical structure and interfacial thermodynamics[J].Water Research, 2020, 185:116237.
11. [11]
  金宝丹, 王淑莹, 邢立群, 等.单过硫酸氢钾复合盐对剩余污泥厌氧发酵的影响[J].东南大学学报(自然科学版), 2016, 46(2):434-443.
12. [12]
  金宝丹, 王淑莹, 邢立群, 等.不同发酵方式对污泥厌氧发酵性能的影响及其发酵液利用[J].中国环境科学, 2016, 36(7):2079-2089.
13. [13]
  JIA T T, WANG Z Z, SHAN H Q, et al.Effect of nanoscale zero-valent iron on sludge anaerobic digestion[J].Resources Conservation & Recycling, 2017, 127:190-195.
14. [14]
  江峰, 孙容容, 梁振声, 等.硫酸盐还原菌处理酸性矿山废水的研究进展[J].华南师范大学学报(自然科学版), 2018, 50(2):25-31.
15. [15]
  ASSOCIATION C, WASHINGTON D A.Standard methods for the examination of water and wastewater[J].American Physical Education Review, 1995, 24:481-489.
16. [16]
  YUAN H Y, CHEN Y G, ZHANG H X, et al.Improved bioproduction of short-chain fatty acids (SCFAs) from excess sludge under alkaline conditions[J].Environmental Science & Technology, 2006, 40:2025-2029.
17. [17]
  GOEL R, MINO T, SATOH H, et al.Enzyme activities under anaerobic and aerobic conditions in activated sludge sequencing batch reactor[J].Water Research, 1998, 32:2081-2088.
18. [18]
  GUO J, KANG Y K, FENG Y.Bioassessment of heavy metal toxicity and enhancement of heavy metal removal by sulfate-reducing bacteria in the presence of zero valent iron[J].Journal of Environmental Management, 2017, 203(1):278-285.
19. [19]
  张跃华, 赵永勋.过硫酸氢钾复合盐消毒作用实验研究[J].中国卫生检验杂志, 2005, 1(15):40-41.
20. [20]
  KANG J, WU W C, LIU W X, et al. Zero-valent iron (ZVI) activation of persulfate (PS) for degradation ofpara-chloronitrobenzene in soil[J]. Bulletin of Environmental Contamination and Toxicology, 2019, 103:140-146.
21. [21]
  LI Y C, XU Z X, WU J X, et al.Efficiency and mechanisms of antimony removal from wastewater using mixed cultures of iron-oxidizing bacteria and sulfate-reducing bacteria based on scrap iron[J].Separation and Purification Technology, 2020, 246:116756.
22. [22]
  JIN B D, WANG S Y, XING L Q, et al.Long term effect of alkali types on waste activated sludge hydrolytic acidification and microbial community at low temperature[J].Bioresource Technology, 2016, 200:587-597.
23. [23]
  JIN B D, NIU J T, DAI J W, et al.New insights into the enhancement of biochemical degradation potential from waste activated sludge with low organic content by potassium monopersulfate treatment[J].Bioresource Technology, 2018, 265:8-16.
24. [24]
  钮劲涛, 金宝丹, 周萍, 等.CaO₂对城市污水处理中剩余污泥厌氧发酵产酸性能与生物酶活性的影响[J].轻工学报, 2019, 34(4):64-73.
25. [25]
  CHEN Y, CHENH J J, KURT S C.Inhibition of anaerobic digestion process:A review[J]. Bioresource Technology, 2008, 99(10):4044.
26. [26]
  AURORE C, ARNAUD C, JEAN C B.Availabi-lity of low and high molecular weight substrates to extracellular enzymes in whole and dispersed activated sludges[J].Enzyme & Microbial Technology, 2002, 31(1/2):179-186.
27. [27]
  HUANG X F, SHEN C M, LIU S, et al.Improved volatile fatty acid production during waste activated sludge anaerobic fermentation by different bio-surfactants[J].Chemical Engineering Journal, 2015, 264:280-290.
28. [28]
  CGROST R J, SIUDA W, ALBRECHT D, et al.A method for determining enzymatically hydrolyzable phosphate (EHP) in natural waters[J].Limnology & Oceanography, 1986, 31(3):662-667.
29. [29]
  KLOEKE F V, GEESEY G G.Localization and identification of populations of phosphatase-active bacterial cells associated with activated sludge flocs[J].Microbial Ecology, 1999, 38:201-214.
1. [1]
  张嫚 , 张国治 , 张康逸 , 何梦影 . 超声辅助酶解法制备小麦ACE抑制肽及其稳定性研究. 轻工学报, 2024, 0(0): -.
2. [2]
  张嫚 , 张国治 , 张康逸 , 何梦影 . 超声辅助酶解法制备小麦ACE抑制肽及其稳定性研究. 轻工学报, 2024, 39(5): 29-39. doi: 10.12187/2024.05.004
3. [3]
  池哲翔 , 廖敏 , 史尚 , 李声毅 , 廖芸 , 丁冬 . 国外烟草活性成分提取及纤维材料利用现状与展望. 轻工学报, 2024, 0(0): -.

点击查看大图

计量

PDF下载量: 13
文章访问数: 2109
引证文献数: 0

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

纳米零价铁协同硫酸盐对低浓度低有机质剩余污泥水解酸化性能的影响

作者简介: 金宝丹(1985-),女,吉林省农安县人,郑州轻工业大学讲师,博士,主要研究方向为污泥减量及资源化利用。E-mail:2016024@zzuli.edu.cn;

Effect of nanoscale zero-valent iron cooperating with sulphate on hydrolytic acidification performance of excess sludge with low concentration and low organic matter

计量

通讯作者: 陈斌, bchen63@163.com

纳米零价铁协同硫酸盐对低浓度低有机质剩余污泥水解酸化性能的影响

作者简介:金宝丹(1985-),女,吉林省农安县人,郑州轻工业大学讲师,博士,主要研究方向为污泥减量及资源化利用。E-mail:2016024@zzuli.edu.cn

English Abstract

Effect of nanoscale zero-valent iron cooperating with sulphate on hydrolytic acidification performance of excess sludge with low concentration and low organic matter

目录

纳米零价铁协同硫酸盐对低浓度低有机质剩余污泥水解酸化性能的影响

作者简介: 金宝丹(1985-),女,吉林省农安县人,郑州轻工业大学讲师,博士,主要研究方向为污泥减量及资源化利用。E-mail:2016024@zzuli.edu.cn;

Effect of nanoscale zero-valent iron cooperating with sulphate on hydrolytic acidification performance of excess sludge with low concentration and low organic matter

计量

文章相关

通讯作者: 陈斌, bchen63@163.com

纳米零价铁协同硫酸盐对低浓度低有机质剩余污泥水解酸化性能的影响

作者简介:金宝丹(1985-),女,吉林省农安县人,郑州轻工业大学讲师,博士,主要研究方向为污泥减量及资源化利用。E-mail:2016024@zzuli.edu.cn

English Abstract

Effect of nanoscale zero-valent iron cooperating with sulphate on hydrolytic acidification performance of excess sludge with low concentration and low organic matter

目录