JOURNAL OF LIGHT INDUSTRY

CN 41-1437/TS  ISSN 2096-1553

固定化卤醇脱卤酶的制备及催化合成ATS-5的稳定性考察

梁国斌 ,  翟良创 ,  汪斌 ,  姚佳 ,  周全法

downloadPDF
梁国斌, 翟良创, 汪斌, 等. 固定化卤醇脱卤酶的制备及催化合成ATS-5的稳定性考察[J]. 轻工学报, 2017, 32(2): 26-32. doi: 10.3969/j.issn.2096-1553.2017.2.005
引用本文: 梁国斌, 翟良创, 汪斌, 等. 固定化卤醇脱卤酶的制备及催化合成ATS-5的稳定性考察[J]. 轻工学报, 2017, 32(2): 26-32. doi: 10.3969/j.issn.2096-1553.2017.2.005
shu
LIANG Guo-bin, ZHAI Liang-chuang, WANG Bin, et al. Preparation of immobilized halohydrin dehalogenase and the stability testing of catalytic systhesis ATS-5[J]. Journal of Light Industry, 2017, 32(2): 26-32. doi: 10.3969/j.issn.2096-1553.2017.2.005
Citation: LIANG Guo-bin, ZHAI Liang-chuang, WANG Bin, et al. Preparation of immobilized halohydrin dehalogenase and the stability testing of catalytic systhesis ATS-5[J]. Journal of Light Industry, 2017, 32(2): 26-32. doi: 10.3969/j.issn.2096-1553.2017.2.005
shu

固定化卤醇脱卤酶的制备及催化合成ATS-5的稳定性考察

  • 江苏理工学院 化学与环境工程学院, 江苏 常州 213001

  • 基金项目: 江苏省产学研联合创新基金项目（BY2015028-04）

  • 中图分类号: Q814.2

Preparation of immobilized halohydrin dehalogenase and the stability testing of catalytic systhesis ATS-5

  • School of Chemical and Environmental Engineering, Jiangsu University of Technology, Changzhou 213001, China

  • Received Date: 2016-06-07
    Available Online: 2017-03-15

    CLC number: Q814.2

  • 摘要: 研究了海藻酸钠固定化卤醇脱卤酶（HHDH）的制备条件，确定其最佳工艺条件为：海藻酸钠浓度3.5%，HHDH给酶量2.4×104 U/mL，戊二醛浓度1.00%，氯化钙浓度1.5%和固化时间2 h.在此条件下，HHDH包埋率为52.1%，活力回收率为75.2%.固定化HHDH间歇催化合成（R）-4-氰基-3-羟基丁酸乙酯（ATS-5），经5批次反应后，相对活力为51.2%；固定化HHDH连续催化合成ATS-5，在10 d后底物转化率为90.6%，ATS-5精馏提纯收率为98.2%，纯度达到99.3%，光学纯度达到99.1%.固定化HHDH在4℃下储存80 d后无明显酶活力损失.
    Abstract: The immobilization conditions of halohydrin dehalogenase (HHDH) by the sodium alginate were studied.The optimum conditions of immobilization process were as follows:sodium alginate concentration 3.5%, HHDH enzymatic amount 2.4×104 U/mL, glutaraldehyde concentration 1.00%, calcium chloride solution concentration 1.5% and immobilization time 2 h.Under the optimum immobilization conditions, the encapsulation efficiency of HHDH was 52.1%, the activity recovery of HHDH was 75.2%.After five batches of intermittent catalytic synthesis of (R)-4-cyano-3-hydroxybutyric acid ethyl (ATS-5), the residual activity of immobilized HHDH was 51.2%. After the continuous catalytic synthesis of ATS-5 for 10 d,the substrate conversion efficiency was 90.6%, the distillation purification yield of ATS-5 was 98.2%, the purity and optical purity of ATS-5 were 99.3% and 99.1%, respectively.No obvious activity loss was obtained for immobilized HHDH after 80 d storage at 4℃.
    1. [1]

      江红,吴永健.阿托伐他汀治疗新进展[J].心血管病学进展,2004(5):335.

    2. [2]

      丁洪,吴林森,陈永乐.四种半合成及全合成他汀类药物的研究与开发[J].药学进展,1999(2):65.

    3. [3]

      KUMAR Y,KUMAR SMD,SATHYANARAYANA S.Process for the production of atorvastatin calcium in amorphous form:20090216029[P].2009-08-27.

    4. [4]

      杨宽,余丽丽,姚琳,等.调血脂药物阿伐他汀的合成路线[J].化工科技,2013(4):71.

    5. [5]

      MOTHANA B,BOYD R J.A density functional theory study of the mechanism of the Paal-Knorr pyrrole synthesis[J].Journal of Molecular Structure Theo Chem,2007,811(1-3):97.

    6. [6]

      金勇,吴坚平,徐刚,等.有机相酶催化氨解反应拆分制备(R)-4-氯-3-羟基丁酸乙酯[J].有机化学,2006(10):1384.

    7. [7]

      钟萍,孙志浩.生物催化不对称还原方法生产(S)-4-氯-3-羟基丁酸乙酯[J].过程工程学报,2005(6):665.

    8. [8]

      LEE H W,KIM Y M,YOO C L,et al.An efficient method for the large-scale synthesis of atorvastatin calcium[J].Biomolecules & Therapeutics,2008,16(1):28.

    9. [9]

      DESANTIS G,WONG K,FARWELL B,et al.Creation of a productive,highly enantioselective nitrilase through gene site saturation mutagenesis (GSSM)[J].Journal of the Hmerican Chemical Society,2003,125(38):11476.

    10. [10]

      WANG L J,LI C X,NI Y,et al.Highly efficient synthesis of chiral alcohols with a novel NADH-dependent reductase from Streptomyces coelicolor[J].Biovesource Technology,2011,102(14):7023.

    11. [11]

      何玉财,陶志成,张丹平,等.(R)-4-氯-3-羟基丁酸乙酯及其衍生物的生物合成方法:104988085[P].2015-10-21.

    12. [12]

      曹林秋.载体固定化酶:原理、应用和设计[M].北京:化学工业出版社,2008.

    13. [13]

      OGINO C,NEGI Y,MATSUMIYA T,et al.Purification,characterization and sequence determination of phospholipase D secreted by streptoverticillium cinnamoneum[J].Journal of Biochemistry,1999,125(2):263.

    14. [14]

      WANG G J,HOLLINGSWORTH R I.Synthetic routes to l-carnitine and l-gamma-amino-beta-hydroxybutyric acid from (S)-3-hydroxybutyrolactone by functional group priority switching[J].Tetrahedron Asymmetr,1999,10(10):1895.

    1. [1]

      张嫚 , 张国治 , 张康逸 , 何梦影 . 超声辅助酶解法制备小麦ACE抑制肽及其稳定性研究. 轻工学报, 2024, 0(0): -.

    2. [2]

      张嫚 , 张国治 , 张康逸 , 何梦影 . 超声辅助酶解法制备小麦ACE抑制肽及其稳定性研究. 轻工学报, 2024, 39(5): 29-39. doi: 10.12187/2024.05.004

    3. [3]

      贾尚羲 , 张怡雪 , 石盼盼 , 王昱 , 李可 . 不同时长超声波处理对鹰嘴豆分离蛋白乳化液稳定性的影响. 轻工学报, 2024, 39(5): 40-49. doi: 10.12187/2024.05.005

    4. [4]

      张改红 , 许航 , 杜帅 , 徐月莹 , 石栋栋 , 薛晶晶 , 尚紫博 , 毛多斌 . 麦芽酚-β-D-葡萄糖苷的稳定性及其在卷烟加香中的应用. 轻工学报, 2024, 39(5): 102-108. doi: 10.12187/2024.05.012

    5. [5]

      张伟伟 , 姬远鹏 , 元春波 , 王君婷 , 齐晓任 , 张卫正 , 李萌 , 饶智 . 基于改进Mask R-CNN模型的粘连烟丝识别方法. 轻工学报, 2024, 39(5): 78-85. doi: 10.12187/2024.05.009

  • 加载中
WeChat 点击查看大图
计量
  • PDF下载量:  30
  • 文章访问数:  1542
  • 引证文献数: 0
文章相关
  • 收稿日期:  2016-06-07
  • 刊出日期:  2017-03-15
通讯作者: 陈斌, bchen63@163.com
  • 1. 

    沈阳化工大学材料科学与工程学院 沈阳 110142

  1. 本站搜索
  2. 百度学术搜索
  3. 万方数据库搜索
  4. CNKI搜索
梁国斌, 翟良创, 汪斌, 等. 固定化卤醇脱卤酶的制备及催化合成ATS-5的稳定性考察[J]. 轻工学报, 2017, 32(2): 26-32. doi: 10.3969/j.issn.2096-1553.2017.2.005
引用本文: 梁国斌, 翟良创, 汪斌, 等. 固定化卤醇脱卤酶的制备及催化合成ATS-5的稳定性考察[J]. 轻工学报, 2017, 32(2): 26-32. doi: 10.3969/j.issn.2096-1553.2017.2.005
shu
LIANG Guo-bin, ZHAI Liang-chuang, WANG Bin, et al. Preparation of immobilized halohydrin dehalogenase and the stability testing of catalytic systhesis ATS-5[J]. Journal of Light Industry, 2017, 32(2): 26-32. doi: 10.3969/j.issn.2096-1553.2017.2.005
Citation: LIANG Guo-bin, ZHAI Liang-chuang, WANG Bin, et al. Preparation of immobilized halohydrin dehalogenase and the stability testing of catalytic systhesis ATS-5[J]. Journal of Light Industry, 2017, 32(2): 26-32. doi: 10.3969/j.issn.2096-1553.2017.2.005
shu

固定化卤醇脱卤酶的制备及催化合成ATS-5的稳定性考察

  • 江苏理工学院 化学与环境工程学院, 江苏 常州 213001
  • 收稿日期: 2016-06-07
  • 网络出版日期: 2017-03-15
基金项目:  江苏省产学研联合创新基金项目（BY2015028-04）

摘要: 研究了海藻酸钠固定化卤醇脱卤酶（HHDH）的制备条件，确定其最佳工艺条件为：海藻酸钠浓度3.5%，HHDH给酶量2.4×104 U/mL，戊二醛浓度1.00%，氯化钙浓度1.5%和固化时间2 h.在此条件下，HHDH包埋率为52.1%，活力回收率为75.2%.固定化HHDH间歇催化合成（R）-4-氰基-3-羟基丁酸乙酯（ATS-5），经5批次反应后，相对活力为51.2%；固定化HHDH连续催化合成ATS-5，在10 d后底物转化率为90.6%，ATS-5精馏提纯收率为98.2%，纯度达到99.3%，光学纯度达到99.1%.固定化HHDH在4℃下储存80 d后无明显酶活力损失.

English Abstract

参考文献 (14) 相关文章 (5)

目录

/

返回文章

网站版权 © 轻工学报编辑部

地址：河南省郑州市科学大道136号邮编：450001

本系统由北京仁和汇智信息技术有限公司开发 技术支持： info@rhhz.net