响应面法优化烟叶中蔗糖酯的超声波萃取工艺

陈凤华; 李山; 贾春晓; 王瑞玲; 王莹莹; 毛多斌

doi:10.3969/j.issn.2095-476X.2013.04.004

CN 41-1437/TS ISSN 2096-1553

响应面法优化烟叶中蔗糖酯的超声波萃取工艺

陈凤华 , 李山 , 贾春晓 , 王瑞玲 , 王莹莹 , 毛多斌

陈凤华, 李山, 贾春晓, 等. 响应面法优化烟叶中蔗糖酯的超声波萃取工艺[J]. 轻工学报, 2013, 28(4): 15-19. doi: 10.3969/j.issn.2095-476X.2013.04.004

引用本文: 陈凤华, 李山, 贾春晓, 等. 响应面法优化烟叶中蔗糖酯的超声波萃取工艺[J]. 轻工学报, 2013, 28(4): 15-19. doi: 10.3969/j.issn.2095-476X.2013.04.004

CHEN Feng-hua, LI Shan, JIA Chun-xiao, et al. Optimization on ultrasonic-assisted extraction technology of sucrose esters from tobacco by response surface methodology[J]. Journal of Light Industry, 2013, 28(4): 15-19. doi: 10.3969/j.issn.2095-476X.2013.04.004

Citation: CHEN Feng-hua, LI Shan, JIA Chun-xiao, et al. Optimization on ultrasonic-assisted extraction technology of sucrose esters from tobacco by response surface methodology[J]. Journal of Light Industry, 2013, 28(4): 15-19. doi: 10.3969/j.issn.2095-476X.2013.04.004

响应面法优化烟叶中蔗糖酯的超声波萃取工艺

郑州轻工业学院材料与化学工程学院, 河南郑州 450001;
郑州轻工业学院烟草科学与工程学院, 河南郑州 450001

通讯作者: 贾春晓

基金项目: 中国烟草总公司卷烟增香保润重大科技专项(110201101025(BR-07))
中图分类号: TS424;TQ651.2

Optimization on ultrasonic-assisted extraction technology of sucrose esters from tobacco by response surface methodology

College of Material and Chemical Engineering, Zhengzhou University of Light Industry, Zhengzhou 450001, China;
College of Tobacco Science and Engineering, Zhengzhou University of Light Industry, Zhengzhou 450001, China

Corresponding author: JIA Chun-xiao,

Received Date: 2013-06-01
Available Online: 2013-07-15
CLC number: TS424;TQ651.2

摘要: 对烟叶中蔗糖酯(SE)的超声波萃取工艺进行了研究.以气相色谱-质谱(GC-MS)法作为分析手段,采用响应面法考察了萃取溶剂、温度、时间和料液比等因素对萃取SE的影响.结果表明,烟叶中SE的最佳萃取条件为:以乙腈为萃取溶剂,料液比为1:29,萃取温度为43℃,时间16 min.在此条件下,烟叶中SE总萃取量的验证值为5.039,理论预测值为5.067;SE的平均回收率为99.87%,与单因素最佳条件下的平均回收率(92.13%)相比提高了7.74%.对10种烟叶样品测定的结果表明,烟叶中SE的种类和含量因产地、品种、等级的不同而有所不同.
- 烟叶 /
- 蔗糖酯 /
- 超声波萃取法 /
- 气相色谱-质谱联用 /
- 响应面法
Abstract: The ultrasonic-assisted extraction technology of sucrose esters (SE) from tobacco was studied.The qualitative and quantitative analysis was performed by gas chromatography-mass spectrometry (GC-MS) method,and the effect of various factors including extraction solvent, temperature,time and solid liquid ratio on the total extract yield of SE was investigated by response surface methodology (RSM).The results showed that the optimal extraction conditions were as follows:the extraction solvent acetonitrile,the solid liquid ratio 1:29,the temperature 43℃ and the extraction time 16 min.Under the optimized conditions,the total extract yield of SE was 5.039 (actual) or 5.067 (theoretical),the average recovery was 99.87%,7.74% more than that obtained under the optimized conditions of single facter tests.The determination results of 10 kinds of tobacco leaf showed that the kinds and content of SE in tobacco leaves were different with different origin,variety and level.
- tobacco /
- sucrose ester /
- ultrasonic extraction /
- GC-MS /
- response surface methodology
1. [1]
  Severson R F,Arrendale R F,Chortyk O T,et al.Isolation and characterization of the sucrose esters of the cuticular waxes of green tobacco leaf[J].Journal of Agricultural and Food Chemistry,1985,33(5):870.
2. [2]
  Schlotzbauer W S,Severson R F,Martin R M.The contribution of sucrose esters to tobacco smoke composition[J].Beitr Tabakfor Int,1986,13(5):229.
3. [3]
  曾世通,李鹏,胡军.低级脂肪酸多元醇混合酯的合成及其在烟草中的加香评价[J].烟草科技,2009(3):33.
4. [4]
  孔光辉,王伟,崔国民.烤烟烟叶腺毛及其分泌物研究进展[J].烟草农业科学,2006,2(3):235.
5. [5]
  Severson R F,Johnson A W,Jackson D M,et al.Cuticular constituents of tobacco:Factors affecting their production and their role in insect and disease resistance and smoke quality[J].Recent Advances in Tobacco Science,1985(11):105.
6. [6]
  Toshiake M,Koushi,Akira K.Germination and growth inhibition of surface lipids from nicotine species and identification of sucrose esters[J].Journal of Agricultural and Food Chemistry,1988,52(8):1889.
7. [7]
  Daniel H J.Biological activity of acyl glucose esters from Datura wrightii glandular trichomes against three nativeinsect herbivores[J].Chemical Ecology,2005(31):1475.
8. [8]
  Breda S,Marija S,Irena V.Analysis of sucrose esters-insecticides from the surface of tobacco plant leaves[J].Journal of Chromatography A,2006,1127:273.
9. [9]
  Noel W,Einolf,Geoffrey C W.Estimation of sucrose esters in tobacco by direct chemical ionization mass spectrometry[J].Journal of Agricultural and Food Chemistry,1984(32):785.
10. [10]
  蔡莉莉,谢复炜,谢剑平.香料烟中蔗糖酯的气相色谱/质谱分析[J].烟草科技,2009(3):40.
11. [11]
  Li D,Xie F,Zhao M,et al.Rapid quantification of sucrose esters in oriental tobacco by liquid chromatography-ion trap mass spectrometry[J].Journal of Separation Science,2007(30):35.
12. [12]
  Mashraf K,Taylor L T,Nazem N,et al.Isolation of tetra-acyl sucrose esters from Turkish tobacco using supercritical fluid CO₂ and comparison with conventional solvent extraction[J].Journal of Agricultural and Food Chemistry,2005(53):1866.
13. [13]
  郭青,林文强,牟定荣,等.超声波萃取技术在烟草成分分离中的应用研究综述[J].郑州轻工业学院学报:自然科学版,2011,26(5):96.
1. [1]
  贾尚羲 , 张怡雪 , 石盼盼 , 王昱 , 李可 . 不同时长超声波处理对鹰嘴豆分离蛋白乳化液稳定性的影响. 轻工学报, 2024, 39(5): 40-49. doi: 10.12187/2024.05.005
2. [2]
  张建栋 , 杨忠泮 , 吴恋恋 , 徐大勇 , 朱萍 , 张雯晶 , 堵劲松 . 基于高光谱成像及机器学习的烟叶糖料液施加量判别模型. 轻工学报, 2024, 39(5): 86-94. doi: 10.12187/2024.05.010
3. [3]
  章存勇 , 庄海锋 , 时雅琪 , 邹鹏 , 丁乃红 , 纵坤 , 贾良元 , 郭东锋 . 国内外雪茄烟叶热解产物差异性研究. 轻工学报, 2024, 0(0): -.
4. [4]
  章存勇 , 庄海锋 , 时雅琪 , 邹鹏 , 丁乃红 , 纵坤 , 贾良元 , 郭东锋 . 国内外雪茄烟叶热解产物差异性研究. 轻工学报, 2024, 39(5): 118-126. doi: 10.12187/2024.05.014
5. [5]
  李敏 , 贺姗姗 , 杨钰雯 . 改良QuEChERS方法结合超高效液相色谱测定火腿肠中杂环胺类化合物. 轻工学报, 2024, 39(5): 60-70. doi: 10.12187/2024.05.007
6. [6]
  刘广超 , 邓莎 , 高峄涵 , 吴涛 , 邓锐杰 . 加热卷烟辊压法薄片丝吸湿性影响因素研究. 轻工学报, 2024, 39(5): 109-117. doi: 10.12187/2024.05.013
7. [7]
  张嫚 , 张国治 , 张康逸 , 何梦影 . 超声辅助酶解法制备小麦ACE抑制肽及其稳定性研究. 轻工学报, 2024, 0(0): -.
8. [8]
  张嫚 , 张国治 , 张康逸 , 何梦影 . 超声辅助酶解法制备小麦ACE抑制肽及其稳定性研究. 轻工学报, 2024, 39(5): 29-39. doi: 10.12187/2024.05.004
9. [9]
  胡新楠 , 朱成凯 , 胡中泽 , 纪执立 , 金伟平 , 郭城 , 沈汪洋 . 复配比对明胶-羟丙基甲基纤维素双水相体系微观结构和流变特性的影响. 轻工学报, 2024, 0(0): -.

点击查看大图

计量

PDF下载量: 30
文章访问数: 961
引证文献数: 0

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

陈凤华, 李山, 贾春晓, 等. 响应面法优化烟叶中蔗糖酯的超声波萃取工艺[J]. 轻工学报, 2013, 28(4): 15-19. doi: 10.3969/j.issn.2095-476X.2013.04.004

引用本文: 陈凤华, 李山, 贾春晓, 等. 响应面法优化烟叶中蔗糖酯的超声波萃取工艺[J]. 轻工学报, 2013, 28(4): 15-19. doi: 10.3969/j.issn.2095-476X.2013.04.004

响应面法优化烟叶中蔗糖酯的超声波萃取工艺

通讯作者: 贾春晓

郑州轻工业学院材料与化学工程学院, 河南郑州 450001;
郑州轻工业学院烟草科学与工程学院, 河南郑州 450001

收稿日期: 2013-06-01
网络出版日期: 2013-07-15

基金项目: 中国烟草总公司卷烟增香保润重大科技专项(110201101025(BR-07))

关键词:

摘要: 对烟叶中蔗糖酯(SE)的超声波萃取工艺进行了研究.以气相色谱-质谱(GC-MS)法作为分析手段,采用响应面法考察了萃取溶剂、温度、时间和料液比等因素对萃取SE的影响.结果表明,烟叶中SE的最佳萃取条件为:以乙腈为萃取溶剂,料液比为1:29,萃取温度为43℃,时间16 min.在此条件下,烟叶中SE总萃取量的验证值为5.039,理论预测值为5.067;SE的平均回收率为99.87%,与单因素最佳条件下的平均回收率(92.13%)相比提高了7.74%.对10种烟叶样品测定的结果表明,烟叶中SE的种类和含量因产地、品种、等级的不同而有所不同.

English Abstract

Optimization on ultrasonic-assisted extraction technology of sucrose esters from tobacco by response surface methodology

Corresponding author: JIA Chun-xiao,

College of Material and Chemical Engineering, Zhengzhou University of Light Industry, Zhengzhou 450001, China;
College of Tobacco Science and Engineering, Zhengzhou University of Light Industry, Zhengzhou 450001, China

Received Date: 2013-06-01
Available Online: 2013-07-15

Abstract: The ultrasonic-assisted extraction technology of sucrose esters (SE) from tobacco was studied.The qualitative and quantitative analysis was performed by gas chromatography-mass spectrometry (GC-MS) method,and the effect of various factors including extraction solvent, temperature,time and solid liquid ratio on the total extract yield of SE was investigated by response surface methodology (RSM).The results showed that the optimal extraction conditions were as follows:the extraction solvent acetonitrile,the solid liquid ratio 1:29,the temperature 43℃ and the extraction time 16 min.Under the optimized conditions,the total extract yield of SE was 5.039 (actual) or 5.067 (theoretical),the average recovery was 99.87%,7.74% more than that obtained under the optimized conditions of single facter tests.The determination results of 10 kinds of tobacco leaf showed that the kinds and content of SE in tobacco leaves were different with different origin,variety and level.

参考文献 (13) 相关文章 (9)