毛霉40899和毛霉M/T混合发酵腐乳的研究

胡永金; 任淑娣; 王知荣; 柴建国; 许佳威; 李世俊; 薛桥丽

doi:10.3969/j.issn.2096-1553.2019.01.001

CN 41-1437/TS ISSN 2096-1553

胡永金 , 任淑娣 , 王知荣 , 柴建国 , 许佳威 , 李世俊 , 薛桥丽

胡永金, 任淑娣, 王知荣, 等. 毛霉40899和毛霉M/T混合发酵腐乳的研究[J]. 轻工学报, 2019, 34(1): 1-10. doi: 10.3969/j.issn.2096-1553.2019.01.001

引用本文: 胡永金, 任淑娣, 王知荣, 等. 毛霉40899和毛霉M/T混合发酵腐乳的研究[J]. 轻工学报, 2019, 34(1): 1-10. doi: 10.3969/j.issn.2096-1553.2019.01.001

HU Yongjin, REN Shudi, WANG Zhirong, et al. Study on Sufu fermented by Mucor 40899 and Mucor M/T[J]. Journal of Light Industry, 2019, 34(1): 1-10. doi: 10.3969/j.issn.2096-1553.2019.01.001

Citation: HU Yongjin, REN Shudi, WANG Zhirong, et al. Study on Sufu fermented by Mucor 40899 and Mucor M/T[J]. Journal of Light Industry, 2019, 34(1): 1-10. doi: 10.3969/j.issn.2096-1553.2019.01.001

毛霉40899和毛霉M/T混合发酵腐乳的研究

1. 云南农业大学食品科学技术学院, 云南昆明 650201;
2. 云南羊泉生物科技股份有限公司, 云南牟定 675500;
3. 云南农业大学学报编辑部, 云南昆明 650201

作者简介: 胡永金(1971-),男,云南省永胜县人,云南农业大学教授,博士,主要研究方向为食品微生物、功能性食品与生物技术.;

基金项目: 云南省科技创新强省专项项目（2016AB016）
中图分类号: TS214.2

Study on Sufu fermented by Mucor 40899 and Mucor M/T

1. College of Food Science and Technology, Yunnan Agricultural University, Kunming 650201, China;
2. Yunnan Yangquan Biotechnology Co., Ltd., Mouding 675500, China;
3. Journal Editorial Department, Yunnan Agricultural University, Kunming 650201, China
Received Date: 2018-07-12

CLC number: TS214.2

摘要: 从腐乳毛坯中分离得到毛霉M/T，以毛霉40899和毛霉M/T为混合发酵剂，采用单因素法和响应面法研究混合菌种发酵腐乳的前发酵工艺，并在最优前发酵条件下考察混合菌种发酵过程中腐乳的氨基酸态氮、质构特性和色度的变化，得出如下结果：经鉴定，毛霉M/T为放射毛霉属；腐乳前发酵最优条件为发酵时间60 h，毛霉40899与毛霉M/T质量比1：1，乳酸pH值3.5.在此条件下，腐乳的蛋白酶活力达到最大值48.015 U/mL.腐乳后发酵至30 d时，腐乳中氨基酸态氮含量为0.53 g/（100 g），达到腐乳行业标准中的成熟标准.腐乳成熟时的硬度、黏附性、弹性等质构特性良好，色差值与市售成熟腐乳接近.
- 腐乳 /
- 毛霉 /
- 混合菌种发酵 /
- 蛋白酶活力
Abstract: Mucor M/T was isolated from sufu pehtze. Using Mucor 40899 and Mucor M/T as mixed starters, the pre-fermentation process of Sufu was studied through single factors and response surface optimization method. Then, the changes of amino acid nitrogen, texture and chromaticity of Sufu fermented by mixed strains were studied under the optimal pre-fermentation conditions. The results showed that Mucor M/T was identified as the Actinomucor. The optimal pre-fermentation conditions were as follows: fermentation time was 60 h, strain quality ratio of Mucor 40899 and Mucor M/T was 1:1, pH value was 3.5. Under the optimal conditions, the protease activity reached 48.015 U/mL. After post-fermentation of 30 d, the content of amino acid nitrogen in Sufu was 0.53 g/(100 g), which met the mature standard in the industry standard of Sufu. The texture, adhesion and elasticity of Sufu were good. The color difference value was close to that of commercially mature fermented Sufu.
- Sufu /
- Mucor /
- mixed fermentation /
- protease activity
1. [1]
  李幼筠,周逦.中国独具特色的发酵豆制品[J].中国酿造, 2010, 217(4):12.
2. [2]
  王瑞芝.中国腐乳酿造[M].2版.北京:中国轻工业出版社, 2009:100.
3. [3]
  刘亚,杨光影,吴悦,等.腐乳进展研究[J].农产品加工(学刊),2013,337(12):64.
4. [4]
  LI Y Y,YU R C,CHOU C C.Some biochemical and physical changes during the preparation of the enzyme-ripening Sufu:a fermented product of soybean curd[J].Journal of Agricultural and Food Chemistry,2010,58(8):4888.
5. [5]
  HANB Z,Rombouts F M,Nout M J R.A Chinese fermented soybean food[J].International Journal of Food Microbiology,2001,65:1.
6. [6]
  ANDUIC S,GENCCELEP H,KOSE S.Determination of biogenic amines in herby cheese[J].International Journal of Food Properties,2010,13(6):1300.
7. [7]
  GUAN R F,LIU Z F,ZHANG J J,et al.Investigation of biogenic amines in sufu (furu):a Chinese traditional fermented soybean food product[J].Food Control,2013,31:345.
8. [8]
  冉春霞,陈光静,阚建全.响应面法优化全豆腐乳前发酵条件的研究[J].食品工业科技,2012,33(18):227.
9. [9]
  赵玉莲,郑学翔.豆腐乳生产用微生物(二)[J].中国酿造,1999(2):9.
10. [10]
  FRANS M,ROMBOUTS M J,ROBERT N,et al.Effect of NaCl on textural changes and protein and lipid degradation during the ripening stage of Sufu:a Chinese fermented soybean food[J].Journal of the Science of Food and Agriculture,2003,83(9):899.
11. [11]
  HAN B Z,ROBERT M J N.Effects of temerature, water activity and gas atmosphere on mycelial growth of tempe fungi Rhizopus microporus var microporus and R microsporus var Oligosporus[J].World Journal of Microbiology & Biotechnology,2000,16(8):853.
12. [12]
  冉春霞,阚建全.全腐乳发酵菌种选择的实验研究[J].中国调味品,2015,18(40):1.
13. [13]
  陈治霖,和七一,陈斌.腐乳毛坯双菌制曲工艺的研究[J].中国调味品,2015,2(40):91.
14. [14]
  李爱华,岳思君,马海滨,等.真菌孢子三种计数方法相关性的探讨[J].微生物学杂志,2006,26(2):107.
15. [15]
  国家标准化管理委员会.蛋白酶制剂:GB/T 23527-2009[S].北京:中国标准出版社,2009.
16. [16]
  刘威,曹蕾蕾,陈春雨,等.少孢根霉发酵腐乳前酵条件优化及发酵全程质构的研究[J].食品工业科技,2014,35(18):228.
17. [17]
  樊巧,陈厚荣,徐晓萍,等.响应面实验优化酪蛋白-魔芋葡甘聚糖共混溶胶制备工艺及其稳定性[J].食品科学,2015,36(24):10.
18. [18]
  中华人民共和国商务部.腐乳:SB/T 10170-2007[S].北京:中国标准出版社,2007.
19. [19]
  鲍松林.腐乳生产菌布氏毛霉的鉴定及其生理特征[J].中国调味品,1994(9):7.
20. [20]
  管立军,程永强,李里特.腐乳和豆豉功能性研究进展[J].中国食物与营养,2008(11):48.
21. [21]
  曹蕾蕾.少孢根霉发酵腐乳过程中主要营养成分变化的研究[D].哈尔滨:东北农业大学,2014.
1. [1]
  张嫚 , 张国治 , 张康逸 , 何梦影 . 超声辅助酶解法制备小麦ACE抑制肽及其稳定性研究. 轻工学报, 2024, 0(0): -.
2. [2]
  张嫚 , 张国治 , 张康逸 , 何梦影 . 超声辅助酶解法制备小麦ACE抑制肽及其稳定性研究. 轻工学报, 2024, 39(5): 29-39. doi: 10.12187/2024.05.004
3. [3]
  尹思睿 , 冯娇 , 杨晓宇 , 李良 . 植物蛋白复配对植物肉品质的影响. 轻工学报, 2024, 39(5): 18-28. doi: 10.12187/2024.05.003
4. [4]
  赵悦 , 闫清泉 , 李玲玉 , 司阔林 , 宗学醒 . 钙螯合盐对牛奶-豌豆双蛋白再制干酪品质的影响. 轻工学报, 2024, 39(5): 1-8. doi: 10.12187/2024.05.001
5. [5]
  吕金羚 , 傅亮 , 陈永生 . 红茶-花生蛋白复合饮品工艺优化及其营养特性研究. 轻工学报, 2024, 0(0): -.
6. [6]
  吕金羚 , 傅亮 , 陈永生 . 红茶-花生蛋白复合饮品工艺优化及其营养特性研究. 轻工学报, 2024, 39(5): 9-17. doi: 10.12187/2024.05.002
7. [7]
  贾尚羲 , 张怡雪 , 石盼盼 , 王昱 , 李可 . 不同时长超声波处理对鹰嘴豆分离蛋白乳化液稳定性的影响. 轻工学报, 2024, 39(5): 40-49. doi: 10.12187/2024.05.005

点击查看大图

计量

PDF下载量: 9
文章访问数: 1385
引证文献数: 0

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

胡永金, 任淑娣, 王知荣, 等. 毛霉40899和毛霉M/T混合发酵腐乳的研究[J]. 轻工学报, 2019, 34(1): 1-10. doi: 10.3969/j.issn.2096-1553.2019.01.001

引用本文: 胡永金, 任淑娣, 王知荣, 等. 毛霉40899和毛霉M/T混合发酵腐乳的研究[J]. 轻工学报, 2019, 34(1): 1-10. doi: 10.3969/j.issn.2096-1553.2019.01.001

HU Yongjin, REN Shudi, WANG Zhirong, et al. Study on Sufu fermented by Mucor 40899 and Mucor M/T[J]. Journal of Light Industry, 2019, 34(1): 1-10. doi: 10.3969/j.issn.2096-1553.2019.01.001

毛霉40899和毛霉M/T混合发酵腐乳的研究

作者简介:胡永金(1971-),男,云南省永胜县人,云南农业大学教授,博士,主要研究方向为食品微生物、功能性食品与生物技术.

1. 云南农业大学食品科学技术学院, 云南昆明 650201;
2. 云南羊泉生物科技股份有限公司, 云南牟定 675500;
3. 云南农业大学学报编辑部, 云南昆明 650201

收稿日期: 2018-07-12

基金项目: 云南省科技创新强省专项项目（2016AB016）

关键词:

摘要: 从腐乳毛坯中分离得到毛霉M/T，以毛霉40899和毛霉M/T为混合发酵剂，采用单因素法和响应面法研究混合菌种发酵腐乳的前发酵工艺，并在最优前发酵条件下考察混合菌种发酵过程中腐乳的氨基酸态氮、质构特性和色度的变化，得出如下结果：经鉴定，毛霉M/T为放射毛霉属；腐乳前发酵最优条件为发酵时间60 h，毛霉40899与毛霉M/T质量比1：1，乳酸pH值3.5.在此条件下，腐乳的蛋白酶活力达到最大值48.015 U/mL.腐乳后发酵至30 d时，腐乳中氨基酸态氮含量为0.53 g/（100 g），达到腐乳行业标准中的成熟标准.腐乳成熟时的硬度、黏附性、弹性等质构特性良好，色差值与市售成熟腐乳接近.

English Abstract

Study on Sufu fermented by Mucor 40899 and Mucor M/T

1. College of Food Science and Technology, Yunnan Agricultural University, Kunming 650201, China;
2. Yunnan Yangquan Biotechnology Co., Ltd., Mouding 675500, China;
3. Journal Editorial Department, Yunnan Agricultural University, Kunming 650201, China

Received Date: 2018-07-12

Abstract: Mucor M/T was isolated from sufu pehtze. Using Mucor 40899 and Mucor M/T as mixed starters, the pre-fermentation process of Sufu was studied through single factors and response surface optimization method. Then, the changes of amino acid nitrogen, texture and chromaticity of Sufu fermented by mixed strains were studied under the optimal pre-fermentation conditions. The results showed that Mucor M/T was identified as the Actinomucor. The optimal pre-fermentation conditions were as follows: fermentation time was 60 h, strain quality ratio of Mucor 40899 and Mucor M/T was 1:1, pH value was 3.5. Under the optimal conditions, the protease activity reached 48.015 U/mL. After post-fermentation of 30 d, the content of amino acid nitrogen in Sufu was 0.53 g/(100 g), which met the mature standard in the industry standard of Sufu. The texture, adhesion and elasticity of Sufu were good. The color difference value was close to that of commercially mature fermented Sufu.