三种跨临界CO<sub>2</sub>制冷循环的性能对比研究

龚毅; 彭锦晨; 吴学红; 张文慧

doi:10.3969/j.issn.2095-476X.2015.3/4.022

CN 41-1437/TS ISSN 2096-1553

三种跨临界CO₂制冷循环的性能对比研究

龚毅 , 彭锦晨 , 吴学红 , 张文慧

龚毅, 彭锦晨, 吴学红, 等. 三种跨临界CO2制冷循环的性能对比研究[J]. 轻工学报, 2015, 30(3-4): 98-102. doi: 10.3969/j.issn.2095-476X.2015.3/4.022

引用本文: 龚毅, 彭锦晨, 吴学红, 等. 三种跨临界CO2制冷循环的性能对比研究[J]. 轻工学报, 2015, 30(3-4): 98-102. doi: 10.3969/j.issn.2095-476X.2015.3/4.022

GONG Yi, PENG Jin-chen, WU Xue-hong and et al. Numerical study for three kinds of transcritical CO2 refrigeration cycle[J]. Journal of Light Industry, 2015, 30(3-4): 98-102. doi: 10.3969/j.issn.2095-476X.2015.3/4.022

Citation: GONG Yi, PENG Jin-chen, WU Xue-hong and et al. Numerical study for three kinds of transcritical CO2 refrigeration cycle[J]. Journal of Light Industry, 2015, 30(3-4): 98-102. doi: 10.3969/j.issn.2095-476X.2015.3/4.022

三种跨临界CO₂制冷循环的性能对比研究

郑州轻工业学院机电工程学院, 河南郑州 450002
基金项目: 郑州市领军人才项目(131PLJRC640)
河南省骨干教师项目(2012GGJS-115)
国家自然科学基金项目(51476148)
中图分类号: TB61

Numerical study for three kinds of transcritical CO₂ refrigeration cycle

College of Mechanical and Electrical Engineering, Zhengzhou University of Light Industry, Zhengzhou 450002, China
Received Date: 2014-06-21
Available Online: 2015-09-15
CLC number: TB61

摘要: 对跨临界CO₂节流阀循环、跨临界CO₂回热器循环、跨临界CO₂膨胀机循环三种跨临界CO₂制冷循环进行了理论分析和模拟计算,研究了三种循环的性能差异.结果表明,相同条件时,回热器循环的制冷量最大,膨胀机循环次之,节流阀循环最小;回热器循环的功耗最大,节流阀循环次之,膨胀机循环最小;膨胀机循环的COP最大,回热器循环次之,节流阀循环最小;回热器循环的压缩机排气温度高于节流阀循环和膨胀机循环.综上可得,节流阀循环的COP最小,回热器循环能够提高系统的制冷量,但是会导致压缩机排气温度的升高,膨胀机循环能够有效地减少系统功耗,对系统COP的提升更为显著,综合性能更好.
- 跨临界CO₂制冷循环 /
- 能效比 /
- 膨胀机循环 /
- 回热器循环 /
- 节流阀循环
Abstract: The performance difference of trans-critical CO₂ throttle valve cycle, trans-critical CO₂ internal heat exchanger cycle and trans-critical CO₂ expander cycle was investigated by theoretical analysis and numerical simulation. The results showed that:under the same conditions, the cooling capacity of internal heat exchanger cycle was the biggest and throttle valve cycle was the smallest; the power dissipation of internal heat exchanger cycle was the biggest and the expander cycle was smallest; the COP of expander cycle was the biggest and throttle valve cycle was the smallest; the compressor discharge temperature of internal heat exchanger cycle was higher than throttle valve cycle and expander cycle.To sum up,the COP of throttle valve cycle was the smallest. Internal heat exchanger cycle could improve the system cooling capacity, but it also increased the compressor discharge temperature. Expander cycle could reduce system power dissipation effectively, and could more significantly improve system COP, it had the better performance.
- transcritical CO₂ refrigeration cycle /
- COP /
- expander cycle /
- internal heat exchanger cycle /
- throttle cycle
1. [1]
  王哲.跨临界CO₂水源热泵与空气源制冷循环试验研究[D].郑州:郑州轻工业学院,2013.
2. [2]
  马一太,魏东,吕灿仁.温室气体减排与CO₂资源化宏观研究与探讨[J].大连理工大学学报,2001(1):9.
3. [3]
  Agrawal N,Bhattacharyya S.Studies on a two-stage transcritical carbon dioxide heat pump cycle with flash intercooling[J].Applied Thermal Engineering,2007(27):299.
4. [4]
  Lorentzen G.Revival of carbon dioxide as a refrigerant[J].International Journal of Refrigeration,1994,17(5):292.
5. [5]
  Yang J L,Ma Y T,Li M X,et al.Exergy analysis of transcritical carbon dioxide refrigeration cycle with an expander[J].Energy,2005,30(7):1162.
6. [6]
  Cassona V,Cecchinatoa L,Corradia M,et al.Optimisation of the throttling system in a CO₂ refrigerating machine[J].International Journal of Refrigeration,2003,26(8):926.
7. [7]
  Shafiei S E,Rasmussen H,Stoustrup J.Modeling supermarket refrigeration systems for demand-side management[J].Energies,2013,6(2):900.
8. [8]
  姜云涛,马一太,张子坤,等.回热器对跨临界CO₂水源热泵的影响判别式及实验研究[J].热科学与技术, 2009,8(4):307.
9. [9]
  Wang Z,Gong Y,Wu X H,et al.Thermodynamic analysis and experimental research of transcritical CO₂ cycle with internal heat exchanger and dual expansion[J].International Journal of Air-Conditioning and Refrigeration,2013,21(1):1.
10. [10]
  Zhang W H,Wang Z,Gong Y,et al.Thermodynamic analysis and experimental investigation of internal heat exchanger influence on CO₂ transcritical cycle performance[J].Advanced Materials Research,2013,614:259.
11. [11]
  杨俊兰,马一太,李敏霞,等.带膨胀机CO₂跨临界热泵系统的模拟计算与实验[J].天津大学学报:自然科学与工程技术,2007,40(9):1099.
12. [12]
  Kim J K,Jeon H K,Lee J S.Wall temperature measurement and heat transfer correlation of turbulent supercritical carbon dioxideflow in vertical circular/non-circular tubes[J].Nuclear Engineering and Design,2007,237(15-17):1795.
13. [13]
  龚毅,侯峰,梁志礼,等.带回热器的跨临界CO₂制冷系统的试验研究[J].流体机械,2011,39(10):56.
1. [1]
  李浩佳 , 贺诗华 , 曹艺泽 , 郭西玉 , 朱由余 , 赵玮钦 , 黄淳 . 以碳量子点为荧光信号的生物传感器构建及其在金银花 Pb²⁺ 检测中的应用. 轻工学报, 2024, 0(0): -.
2. [2]
  章存勇 , 庄海锋 , 时雅琪 , 邹鹏 , 丁乃红 , 纵坤 , 贾良元 , 郭东锋 . 国内外雪茄烟叶热解产物差异性研究. 轻工学报, 2024, 0(0): -.
3. [3]
  章存勇 , 庄海锋 , 时雅琪 , 邹鹏 , 丁乃红 , 纵坤 , 贾良元 , 郭东锋 . 国内外雪茄烟叶热解产物差异性研究. 轻工学报, 2024, 39(5): 118-126. doi: 10.12187/2024.05.014

点击查看大图

计量

PDF下载量: 33
文章访问数: 889
引证文献数: 0

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

龚毅, 彭锦晨, 吴学红, 等. 三种跨临界CO2制冷循环的性能对比研究[J]. 轻工学报, 2015, 30(3-4): 98-102. doi: 10.3969/j.issn.2095-476X.2015.3/4.022

引用本文: 龚毅, 彭锦晨, 吴学红, 等. 三种跨临界CO2制冷循环的性能对比研究[J]. 轻工学报, 2015, 30(3-4): 98-102. doi: 10.3969/j.issn.2095-476X.2015.3/4.022

三种跨临界CO₂制冷循环的性能对比研究

郑州轻工业学院机电工程学院, 河南郑州 450002

收稿日期: 2014-06-21
网络出版日期: 2015-09-15

基金项目: 郑州市领军人才项目(131PLJRC640)河南省骨干教师项目(2012GGJS-115)国家自然科学基金项目(51476148)

关键词:

摘要: 对跨临界CO₂节流阀循环、跨临界CO₂回热器循环、跨临界CO₂膨胀机循环三种跨临界CO₂制冷循环进行了理论分析和模拟计算,研究了三种循环的性能差异.结果表明,相同条件时,回热器循环的制冷量最大,膨胀机循环次之,节流阀循环最小;回热器循环的功耗最大,节流阀循环次之,膨胀机循环最小;膨胀机循环的COP最大,回热器循环次之,节流阀循环最小;回热器循环的压缩机排气温度高于节流阀循环和膨胀机循环.综上可得,节流阀循环的COP最小,回热器循环能够提高系统的制冷量,但是会导致压缩机排气温度的升高,膨胀机循环能够有效地减少系统功耗,对系统COP的提升更为显著,综合性能更好.