粒径对熟制风味龙虾中香辛料品质的影响

刘晓丽; 姜伯成; 姜启兴; 杨方; 周小燕; 沈慧敏; 陈诺; 夏文水

doi:10.12187/2022.02.003

CN 41-1437/TS ISSN 2096-1553

粒径对熟制风味龙虾中香辛料品质的影响

刘晓丽 , 姜伯成 , 姜启兴 , 杨方 , 周小燕 , 沈慧敏 , 陈诺 , 夏文水

刘晓丽, 姜伯成, 姜启兴, 等. 粒径对熟制风味龙虾中香辛料品质的影响[J]. 轻工学报, 2022, 37(2): 23-29. doi: 10.12187/2022.02.003

引用本文: 刘晓丽, 姜伯成, 姜启兴, 等. 粒径对熟制风味龙虾中香辛料品质的影响[J]. 轻工学报, 2022, 37(2): 23-29. doi: 10.12187/2022.02.003

LIU Xiaoli, JIANG Bocheng, JIANG Qixing, et al. Effect of particle size on quality of spices in cooked flavor crayfish[J]. Journal of Light Industry, 2022, 37(2): 23-29. doi: 10.12187/2022.02.003

Citation: LIU Xiaoli, JIANG Bocheng, JIANG Qixing, et al. Effect of particle size on quality of spices in cooked flavor crayfish[J]. Journal of Light Industry, 2022, 37(2): 23-29. doi: 10.12187/2022.02.003

粒径对熟制风味龙虾中香辛料品质的影响

1. 江南大学食品学院/食品科学与技术国家重点实验室/江苏省食品安全与质量控制协同创新中心, 江苏无锡 214122;
2. 东台市天海土特产有限公司, 江苏东台 224200

作者简介: 刘晓丽(1984—),女,甘肃省天水市人,江南大学副研究员,博士,主要研究方向为食品加工及保藏保鲜。E-mail:lxl525j@163.com;

基金项目: 国家重点研发计划项目(2019YFC1606002)
江苏省苏北专项项目(SZ-YC202003)
中图分类号: TS251.5⁺5

Effect of particle size on quality of spices in cooked flavor crayfish

1. School of Food Science and Technology/State Key Laboratory of Food Science and Technology/Collaborative Innovation Center of Food Safety and Quality Control in Jiangsu Province, Jiangnan University, Wuxi 214122, China;
2. Dongtai Tianhai Native Products Co., Ltd., Dongtai 224200, China
Received Date: 2021-08-11
Accepted Date: 2022-03-04

CLC number: TS251.5⁺5

摘要: 以熟制风味龙虾的香辛料为研究对象,通过对其进行微粉碎处理和筛分,研究不同粉碎粒径香辛料的休止角、滑角、膨胀力和溶出效果,并对香辛料汤汁的色泽、感官、挥发性风味成分和添加量进行分析。结果表明:微粉碎处理后,香辛料的休止角和滑角均随粒径的减小而逐渐增大,膨胀力则逐渐减小;在820~1500 μm粒径范围内的香辛料溶出效果较好,利用率提高,香气更浓郁;与未粉碎香辛料相比,820 μm粒径香辛料中的主要挥发性风味成分相对含量较高,即其最适宜熬煮熟制风味龙虾的汤汁,且添加量取3~4 g/L较好。
- 香辛料 /
- 粒径 /
- 微粉碎 /
- 熟制风味龙虾
Abstract: Taking the spices in cooked flavor craytish as the research object, the angle of repose, the slip angle, the swelling capacity and the dissolution effect of different particle size were studied after micro-grinding and screening. In addition, the color, sensory, volatile flavor components and adding amount of the boiled liquid of the spices were compared and analyzed. The results showed that with the decrease of particle size, the angle of repose and the slip angle of the material increased gradually, while the swelling capacity decreased gradually. Spices of 820~1500 μm could achieve the highest spice dissolution effect and the most intense aroma. Compared with the original size of spices, relative content of volatile flavor compounds in 820 μm spices was higher. The 820 μm spices was the most suitable for cooking the soup of cooked flavor craytish and its additive amount was 3~4 g/L.
- spice /
- particle size /
- micro-grinding /
- cooked flavor crayfish
1. [1]
  曾诗淇.小龙虾大市场:解析《中国小龙虾产业发展报告(2018)》[J].农产品市场周刊,2018(24):10-12.
2. [2]
  张刘蕾,姜启兴,许艳顺,等.油炸和真空渗透对冻藏风味小龙虾品质的影响[J].郑州轻工业学院学报(自然科学版),2013,28(4):40-44.
3. [3]
  李晚成,王玉洁,徐素素,等.粉末香辛料投放方式对减盐卤鸭腿品质特性的影响[J].肉类研究,2021,35(5):23-28.
4. [4]
  薛永霞,张作乾,张洪才,等.不同加工阶段对上海熏鱼(草鱼)风味物质的影响[J].食品科学,2019,40(16):160-168.
5. [5]
  吴耀军.辛香料的加工与安全应用[C]//第十届中国国际食品添加剂和配料展览会学术论文集(2006年卷).上海:中国食品添加剂生产应用工业协会,2006:223-225.
6. [6]
  杨春瑜,柳双双,梁佳钰,等.超微粉碎对食品理化性质影响的研究[J].食品研究与开发,2019,40(1):220-224.
7. [7]
  刘月如,王海林,杨茂,等.超微化膳食纤维功能特性的研究进展[J].食品科技,2020,45(3):64-68.
8. [8]
  ZHANGA Z P,ZHANGA R J,XIAO H,et al. Development of a standardized food model for studying the impact of food matrix effects on the gastrointestinal fate and toxicity of ingested nanomaterials[J].Nano Impact,2019,13:13-25.
9. [9]
  ZHAO X Y,ZHU H T,ZHANG G X,et al.Effect of superfine grinding on the physicochemical properties and antioxidant activity of red grape pomace powders[J].Powder Technology,2015,286:838-844.
10. [10]
  ZARAI Z,BOUJELBENE E,SALEM N B.Antioxidant and antimicrobial activities of various solvent extracts, piperine and piperic acid from Piper nigrum[J].LWT-Food Science and Technology,2013,50(2):634-641.
11. [11]
  KARAMA M C,PETIT J,ZIMMER D,et al.Effects of drying and grinding in production of fruit and vegetable powders: A review[J].Journal of Food Engineering,2016,188:32-49.
12. [12]
  李昌文,张丽华,胡少帅,等.超微粉碎对芹菜渣理化特性的影响[J].食品工业,2021,42(7):150-153.
13. [13]
  梁琪,毕阳,米兰,等.沙枣细粉超微粉碎后对物化特性的影响研究[J].食品工业科技,2012,33(11):76-78.
14. [14]
  LIU C,HAN J Y,DUAN Y Q,et al. Purification and quantification of ginsenoside Rb3 and Rc from crude extracts of caudexes and leaves of Panax notoginseng[J].Separation and Purification Technology,2007,54(2):198-203.
15. [15]
  李渐鹏,尚玉荣,刘润书,等.麦麸超微粉-淀粉混合体系理化特性研究[J].食品工业科技,2016,37(3):92-96.
16. [16]
  王珏,宋宗庆,李春保,等.香瓜子汤料水用香辛料煮制特性研究[J].安徽农业科学,2011,39(14):8609-8611.
17. [17]
  牛潇潇.超微粉碎马铃薯渣理化性质和功能特性的研究[D].呼和浩特:内蒙古农业大学,2021.
18. [18]
  程佳钰,高利,汤晓智.超微粉碎对苦荞面条品质特性的影响[J].食品科学,2021,42(15):99-105.
1. [1]
  吴晓东 , 刘畅 , 李俊 , 胡良志 , 贺凌晨 , 袁海霞 , 李强 , 黄锦标 . 基于高光谱检测的烟丝加香均匀性表征方法. 轻工学报, 2024, 39(5): 95-101. doi: 10.12187/2024.05.011
2. [2]
  赵悦 , 闫清泉 , 李玲玉 , 司阔林 , 宗学醒 . 钙螯合盐对牛奶-豌豆双蛋白再制干酪品质的影响. 轻工学报, 2024, 39(5): 1-8. doi: 10.12187/2024.05.001
3. [3]
  张改红 , 许航 , 杜帅 , 徐月莹 , 石栋栋 , 薛晶晶 , 尚紫博 , 毛多斌 . 麦芽酚-β-D-葡萄糖苷的稳定性及其在卷烟加香中的应用. 轻工学报, 2024, 39(5): 102-108. doi: 10.12187/2024.05.012

点击查看大图

计量

PDF下载量: 12
文章访问数: 2745
引证文献数: 0

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

刘晓丽, 姜伯成, 姜启兴, 等. 粒径对熟制风味龙虾中香辛料品质的影响[J]. 轻工学报, 2022, 37(2): 23-29. doi: 10.12187/2022.02.003

引用本文: 刘晓丽, 姜伯成, 姜启兴, 等. 粒径对熟制风味龙虾中香辛料品质的影响[J]. 轻工学报, 2022, 37(2): 23-29. doi: 10.12187/2022.02.003

LIU Xiaoli, JIANG Bocheng, JIANG Qixing, et al. Effect of particle size on quality of spices in cooked flavor crayfish[J]. Journal of Light Industry, 2022, 37(2): 23-29. doi: 10.12187/2022.02.003

粒径对熟制风味龙虾中香辛料品质的影响

作者简介:刘晓丽(1984—),女,甘肃省天水市人,江南大学副研究员,博士,主要研究方向为食品加工及保藏保鲜。E-mail:lxl525j@163.com

1. 江南大学食品学院/食品科学与技术国家重点实验室/江苏省食品安全与质量控制协同创新中心, 江苏无锡 214122;
2. 东台市天海土特产有限公司, 江苏东台 224200

收稿日期: 2021-08-11
录用日期: 2022-03-04

基金项目: 国家重点研发计划项目(2019YFC1606002)江苏省苏北专项项目(SZ-YC202003)

关键词:

摘要: 以熟制风味龙虾的香辛料为研究对象,通过对其进行微粉碎处理和筛分,研究不同粉碎粒径香辛料的休止角、滑角、膨胀力和溶出效果,并对香辛料汤汁的色泽、感官、挥发性风味成分和添加量进行分析。结果表明:微粉碎处理后,香辛料的休止角和滑角均随粒径的减小而逐渐增大,膨胀力则逐渐减小;在820~1500 μm粒径范围内的香辛料溶出效果较好,利用率提高,香气更浓郁;与未粉碎香辛料相比,820 μm粒径香辛料中的主要挥发性风味成分相对含量较高,即其最适宜熬煮熟制风味龙虾的汤汁,且添加量取3~4 g/L较好。

English Abstract

Effect of particle size on quality of spices in cooked flavor crayfish

1. School of Food Science and Technology/State Key Laboratory of Food Science and Technology/Collaborative Innovation Center of Food Safety and Quality Control in Jiangsu Province, Jiangnan University, Wuxi 214122, China;
2. Dongtai Tianhai Native Products Co., Ltd., Dongtai 224200, China

Received Date: 2021-08-11
Accepted Date: 2022-03-04

Abstract: Taking the spices in cooked flavor craytish as the research object, the angle of repose, the slip angle, the swelling capacity and the dissolution effect of different particle size were studied after micro-grinding and screening. In addition, the color, sensory, volatile flavor components and adding amount of the boiled liquid of the spices were compared and analyzed. The results showed that with the decrease of particle size, the angle of repose and the slip angle of the material increased gradually, while the swelling capacity decreased gradually. Spices of 820~1500 μm could achieve the highest spice dissolution effect and the most intense aroma. Compared with the original size of spices, relative content of volatile flavor compounds in 820 μm spices was higher. The 820 μm spices was the most suitable for cooking the soup of cooked flavor craytish and its additive amount was 3~4 g/L.

参考文献 (18) 相关文章 (3)