JOURNAL OF LIGHT INDUSTRY

CN 41-1437/TS  ISSN 2096-1553

基于热流分析法的加热卷烟烟具能耗控制研究

唐伟 ,  陈昆 ,  陈佳琦 ,  潘福敏 ,  刘洪佚

downloadPDF
唐伟, 陈昆, 陈佳琦, 等. 基于热流分析法的加热卷烟烟具能耗控制研究[J]. 轻工学报, 2023, 38(3): 119-126. doi: 10.12187/2023.03.015
引用本文: 唐伟, 陈昆, 陈佳琦, 等. 基于热流分析法的加热卷烟烟具能耗控制研究[J]. 轻工学报, 2023, 38(3): 119-126. doi: 10.12187/2023.03.015
shu
TANG Wei, CHEN Kun, CHEN Jiaqi, et al. Research on efficient heat utilization of heated tobacco device based on heat flow analysis method[J]. Journal of Light Industry, 2023, 38(3): 119-126. doi: 10.12187/2023.03.015
Citation: TANG Wei, CHEN Kun, CHEN Jiaqi, et al. Research on efficient heat utilization of heated tobacco device based on heat flow analysis method[J]. Journal of Light Industry, 2023, 38(3): 119-126. doi: 10.12187/2023.03.015
shu

基于热流分析法的加热卷烟烟具能耗控制研究

  • 南通烟滤嘴有限责任公司 研发中心, 江苏 南通 226014

    • 作者简介: 唐伟(1987-),男,江苏省南通市人,南通烟滤嘴有限责任公司工程师,主要研究方向为新型烟草及烟用滤棒技术。E-mail:twntdx@163.com;

  • 基金项目: 江苏中烟工业有限责任公司科技项目(202204,H202114)
    中国烟草总公司科技重大专项(110202101077(XX-22))

  • 中图分类号: TS43

Research on efficient heat utilization of heated tobacco device based on heat flow analysis method

  • R&D Center, Nantong Cigarette Filter Co., Ltd., Nantong 226014, China

  • Received Date: 2022-06-14
    Accepted Date: 2022-06-29

    CLC number: TS43

  • 摘要: 基于TRIZ理论的流分析方法识别加热卷烟烟具传热过程的有效流和有害流,提出烟具容纳管结构优化、气道管结构简化、加热元件温度场调整等烟具降能耗优化方案,并在iRod烟具能耗控制过程中验证该方案的科学性与实用性。结果表明:改进后的加热卷烟烟具在保持感官吸味不变甚至略微提高的情况下,能耗降低约11.1%,加热卷烟续航提升2支;同时烟具外壳温度降低3.3℃,烟具握持手感显著提升。
    Abstract: The flow analysis method based on TRIZ theory identifies the effective flow and harmful flow in the heat transfer process of the heated tobacco device, and proposes an optimization scheme for reducing energy consumption of the heated tobacco device, such as the structure optimization of the containing tube, the simplification of the airway tube, and the adjustment of the temperature distribution of the heater, and the scientificalness and practicability of the method in the energy consumption control process of iRod was verified. The results showed that: under the same taste, iRod reduced energy consumption by 11.1%, and increased the usage of 2 heated tobacco; at the same time, the temperature on the surface of the iRod was reduced by more than 3.3 ℃, the sense of touch is improved obviously.
    1. [1]

      ADAM T,MITSCHKE S,STREIBEL T,et al.Quantitative puff-by-puff-resolved characterization of selected toxic compounds in cigarette mainstream smoke[J].Chemical Research in Toxicology,2006,19(4):511-520.

    2. [2]

      PRYOR W A,PRIER D G,CHURCH D F.Electron-spin resonance study of mainstream and sidestream cigarette smoke:Nature of the free radicals in gas-phase smoke and in cigarette tar[J].Environmental Health Perspectives,1983,47:345-355.

    3. [3]

      HEIDE J,ADAM T W,JACOBS E,et al.Puff-resolved analysis and selected quantification of chemicals in the gas phase of E-cigarettes,heat-not-burn devices,and conventional cigarettes using Single-Photon Ionization Time-of-Flight Mass Spectrometry (SPI-TOFMS):A comparative study[J].Nicotine and Tobacco Research,2021,23(12):2135-2144.

    4. [4]

      PRYOR W A,CHURCH D F,EVANS M D,et al.A comparison of the free radical chemistry of tobacco-burning cigarettes and cigarettes that only heat tobacco[J].Free Radical Biology & Medicine,1990,8(3):275-279.

    5. [5]

      DEBETHIZY J D,BORGERDING M F,DOOLITTLE D J,et al.Chemical and biological studies of a cigarette that heats rather than burns tobacco[J].The Journal of Clinical Pharmacology,1990,30(8):755-763.

    6. [6]

      TITZ B,BOUÉ S,PHILLIPS B,et al.Effects of cigarette smoke,cessation,and switching to two heat-not-burn tobacco products on lung lipid metabolism in C57BL/6 and Apoe -/- Mice:An integrative systems toxicology analysis[J].Toxicological Sciences,2016,149(2):441-457.

    7. [7]

      HOENG J,PEITSCH M C.Toxicological evaluation of electronic nicotine delivery products[M].Massachusetts:Academic Press,2021:23-40.

    8. [8]

      FARSALINOS K E,YANNOVITS N,SARRI T,et al.Nicotine delivery to the aerosol of a heat-not-burn tobacco product:Comparison with a tobacco cigarette and e-cigarettes[J].Nicotine and Tobacco Research,2018,20(8):1004-1009.

    9. [9]

      DAVIS B,TO V,TALBOT P.Comparison of cytotoxicity of IQOS aerosols to smoke from Marlboro Red and 3R4F reference cigarettes[J].Toxicology in Vitro,2019,61:104652.

    10. [10]

      周昆,杨继,杨柳,等.加热不燃烧卷烟气溶胶研究进展[J].中国烟草学报,2017,23(5):141-149.

    11. [11]

      龚淑果,刘巍,黄平,等.加热不燃烧卷烟烟气主要成分的逐口释放行为[J].烟草科技,2019,52(2):62-71.

    12. [12]

      司晓喜,张凤梅,朱瑞芝,等.6种香料在加热条件下的释放迁移及对气溶胶理化特性的影响[J].轻工学报, 2021,36(5):67-75.

    13. [13]

      司晓喜,崔华鹏,朱瑞芝,等.不同GL/PG质量比和添加总量对加热卷烟气溶胶逐口释放特性的影响[J].轻工学报,2022,37(2):78-86.

    14. [14]

      李朝建,饶先立,郑晓云,等.不同工艺制备的加热卷烟烟草薄片热失重行为研究[J].轻工学报,2022,37(1):55-61.

    15. [15]

      陈芝飞,陈泽少,罗灿选,等.加热卷烟气溶胶中6种酯类单体香料转移行为研究[J].轻工学报,2022,37(3):58-64.

    16. [16]

      EATON D,JAKAJ B,FORSTER M,et al.Assessment of tobacco heating product THP1.0.Part 2:Product design, operation and thermophysical characterisation[J].Regulatory Toxicology and Pharmacology,2018,93:4-13.

    17. [17]

      COZZANI V,BARONTINI F,MCGRATH T,et al.An experimental investigation into the operation of an electrically heated tobacco system[J].Thermochimica Acta,2020,684:178475.

    18. [18]

      崔华鹏,陈黎,樊美娟,等.电加热卷烟气溶胶物理特性的表征[J].轻工学报,2022,37(2):87-93
      ,101.

    19. [19]

      Philip Morris Products SA.Aerosol-generating article having an adjustable heating area:CN202080041533.8[P].2022-01-18.

    20. [20]

      孙剑韬,陈义坤,刘磊,等.加热不燃烧型雾化系统传热仿真分析[J].武汉大学学报(工学版),2021,(7):668-674.

    21. [21]

      LAVANCHY F,MALGAT A.Aerosol generating article including a heat-conducting element and a surface treatment[P].America:US10842190B2,2020-11-24.

    22. [22]

      赵新军,孔祥伟.TRIZ创新方法及应用案例分析[M].北京:化学工业出版社,2020.

    23. [23]

      赵敏,张武城,王冠殊.TRIZ进阶及实战:大道至简的发明方法[M].北京:机械工业出版社,2015.

    24. [24]

      杨世铭,陶文铨.传热学(第4版)[Heat Transfer] [M].北京:高等教育出版社,2006.

    1. [1]

      刘广超 , 邓莎 , 高峄涵 , 吴涛 , 邓锐杰 . 加热卷烟辊压法薄片丝吸湿性影响因素研究. 轻工学报, 2024, 39(5): 109-117. doi: 10.12187/2024.05.013

    2. [2]

      卢晓波 , 徐海 , 朱俊召 , 张宇 , 谭健 , 高冠男 , 胡军华 , 林龙 . 基于机器视觉的加热卷烟烟支端部质量检测系统设计. 轻工学报, 2024, 0(0): -.

    3. [3]

      张改红 , 许航 , 杜帅 , 徐月莹 , 石栋栋 , 薛晶晶 , 尚紫博 , 毛多斌 . 麦芽酚-β-D-葡萄糖苷的稳定性及其在卷烟加香中的应用. 轻工学报, 2024, 39(5): 102-108. doi: 10.12187/2024.05.012

  • 加载中
WeChat 点击查看大图
计量
  • PDF下载量:  24
  • 文章访问数:  2387
  • 引证文献数: 0
文章相关
  • 收稿日期:  2022-06-14
  • 修回日期:  2022-06-29
通讯作者: 陈斌, bchen63@163.com
  • 1. 

    沈阳化工大学材料科学与工程学院 沈阳 110142

  1. 本站搜索
  2. 百度学术搜索
  3. 万方数据库搜索
  4. CNKI搜索
唐伟, 陈昆, 陈佳琦, 等. 基于热流分析法的加热卷烟烟具能耗控制研究[J]. 轻工学报, 2023, 38(3): 119-126. doi: 10.12187/2023.03.015
引用本文: 唐伟, 陈昆, 陈佳琦, 等. 基于热流分析法的加热卷烟烟具能耗控制研究[J]. 轻工学报, 2023, 38(3): 119-126. doi: 10.12187/2023.03.015
shu
TANG Wei, CHEN Kun, CHEN Jiaqi, et al. Research on efficient heat utilization of heated tobacco device based on heat flow analysis method[J]. Journal of Light Industry, 2023, 38(3): 119-126. doi: 10.12187/2023.03.015
Citation: TANG Wei, CHEN Kun, CHEN Jiaqi, et al. Research on efficient heat utilization of heated tobacco device based on heat flow analysis method[J]. Journal of Light Industry, 2023, 38(3): 119-126. doi: 10.12187/2023.03.015
shu

基于热流分析法的加热卷烟烟具能耗控制研究

    作者简介:唐伟(1987-),男,江苏省南通市人,南通烟滤嘴有限责任公司工程师,主要研究方向为新型烟草及烟用滤棒技术。E-mail:twntdx@163.com
  • 南通烟滤嘴有限责任公司 研发中心, 江苏 南通 226014
  • 收稿日期: 2022-06-14
  • 录用日期: 2022-06-29
基金项目:  江苏中烟工业有限责任公司科技项目(202204,H202114)中国烟草总公司科技重大专项(110202101077(XX-22))

摘要: 基于TRIZ理论的流分析方法识别加热卷烟烟具传热过程的有效流和有害流,提出烟具容纳管结构优化、气道管结构简化、加热元件温度场调整等烟具降能耗优化方案,并在iRod烟具能耗控制过程中验证该方案的科学性与实用性。结果表明:改进后的加热卷烟烟具在保持感官吸味不变甚至略微提高的情况下,能耗降低约11.1%,加热卷烟续航提升2支;同时烟具外壳温度降低3.3℃,烟具握持手感显著提升。

English Abstract

参考文献 (24) 相关文章 (3)

目录

/

返回文章

网站版权 © 轻工学报编辑部

地址：河南省郑州市科学大道136号邮编：450001

本系统由北京仁和汇智信息技术有限公司开发 技术支持： info@rhhz.net