基于TG-FTIR技术的竹粉热解特性及其动力学行为分析
Pyrolysis characteristics and kinetics behavior analysis of bamboo powder using TG-FTIR
-
摘要: 以竹粉为研究对象，采用热重-红外联用分析技术和分布活化能模型研究其在较宽升温速率范围（20℃/min、50℃/min、100℃/min）内的热解气体释放特性和热解动力学行为.结果表明：竹粉的热解过程经历了干燥预热、快速热解及炭化3个阶段，升温速率的提高使得热解失重曲线和微分失重曲线均向高温侧偏移，同时增加了最大失重速率，有利于挥发成分的充分析出；竹粉热解气体释放相对含量较多的是CO2，其次为醛、酮、酸类及芳香烃、烷烃、酚类等有机组分.竹粉的热解活化能随其转化率的增加波动明显，转化率在0.10~0.25间主要发生半纤维素的热解反应，活化能逐渐升高，转化率在0.25~0.80时主要发生纤维素、木质素分解及热解焦的二次分解反应，活化能整体上在219.7~268.8 kJ/mol间波动.Abstract: The pyrolysis gas release behavior and pyrolysis kinetics characteristics of bamboo powder were investigated by using TG-FTIR instrument and distributed activation energy model (DAEM) under a wide range of heating rates (20 ℃/min,50 ℃/min,and 100 ℃/min).The results showed that the pyrolysis process of bamboo powder experienced three stages,that was,the preheating drying stage,fast degradation stage and carbonization stage.The pyrolysis weight loss curve and differential weight loss curve shifted to the high temperature side with the increase of heating rate.The maximum of mass loss rate also increased as the heating rate increased,which was conducive to the full release of volatile components.The prominent volatile components released during the pyrolysis process of bamboo were CO2,aldehydes,ketones,organic acids and aromatic hydrocarbon,alkanes,phenols,etc.The activation energies fluctuated obviously with the conversion degree.The activation energies increased gradually with conversion degree during 0.10 and 0.25.During 0.25 and 0.80,the decomposition of cellulose/lignin and secondary decomposition of coke occurred,and the activation energies ranged from 219.7 kJ/mol to 268.8 kJ/mol.
-
-
[1]
董庆,张书平,张理,等.竹材热解动力学特性分析[J].过程工程学报,2015,15(1):89.
-
[2]
MA Z Q,CHEN D Y,GU J,et al.Determination of pyrolysis characteristics and kinetics of palm kernel shell using TGA-FTIR and model-free integral methods[J].Energy Conversion and Management,2015,89:251.
-
[3]
LI B S,LYU W,ZHANG Q,et al.Pyrolysis and catalytic pyrolysis of industrial lignins by TG-FTIR:kinetics and products[J].Journal of Analytical and Applied Pyrolysis,2014,108:295.
-
[4]
JIANG Z H,LIU Z J,FEI B H,et al.The pyrolysis characteristics of moso bamboo[J].Journal of Analytical and Applied Pyrolysis,2012,94:48.
-
[5]
TIAN B,QIAO Y Y,TIAN Y Y,et al.Investigation on the effect of particle size and heating rate on pyrolysis characteristics of a bituminous coal by TG-FTIR[J].Journal of Analytical and Applied Pyrolysis,2016,121:376.
-
[6]
王浚浩,张雨,杨优优,等.微藻种类对其热解质量损失规律和产物及动力学的影响[J].农业工程学报,2018,34(19):239.
-
[7]
YANG J L,CHEN H X,ZHAO W T,et al.Combustion kinetics and emission characteristics of peat by using TG-FTIR technique[J].Journal of Thermal Analysis and Calorimetry,2016,124(1):519.
-
[8]
王昭,戴亚,马扩彦,等.基于分布活化能模型的烟草燃烧动力学特性研究[J].烟草科技,2016,49(12):71.
-
[9]
LI C S,SUZUKI K.Kinetic analyses of biomass tar pyrolysis using the distributed activation energy model by TG/DTA technique[J].Journal of Thermal Analysis and Calorimetry,2009,98(1):261.
-
[10]
LI Z Q,LIU C L,CHEN Z C,et al.Analysis of coals and biomass pyrolysis using the distributed activation energy model[J].Bioresource Technology,2009,100(2):948.
-
[11]
GARCÍA R,PIZARRO C,LAVÍN A G,et al.Biomass proximate analysis using thermogravimetry[J].Bioresource Technology,2013,139:1.
-
[12]
MIURA K,MAKI T.A Simple method for estimating f(E) and k0(E) in the distributed activation energy model[J].Energy & Fuels,1998,12(5):864.
-
[13]
KIM D,LEE K,BAE D,et al.Characterizations of biochar from hydrothermal carbonization of exhausted coffee residue[J].Journal of Material Cycles & Waste Management,2016,19(3):1.
-
[14]
LI D M,CHEN L M,ZHANG X W,et al.Pyrolytic characteristics and kinetic studies of three kinds of red algae[J].Biomass and Bioenergy,2011,35(5):1765.
-
[15]
YAN J W,JIANG X M,HAN X X,et al.A TG-FTIR investigation to the catalytic effect of mineral matrix in oil shale on the pyrolysis and combustion of kerogen[J].Fuel,2013,104:307.
-
[16]
马中青,徐嘉炎,叶结旺,等.基于热重红外联用和分布活化能模型的樟子松热解机理研究[J].西南林业大学学报,2015,35(3):90.
-
[17]
ANCA-COUCE A.Reaction mechanisms and multi-scale modelling of lignocellulosic biomass pyrolysis[J].Progress in Energy and Combustion Science,2016,53:41.
-
[18]
MA Z Q,WANG J H,YANG Y Y,et al.Comparison of the thermal degradation behaviors and kinetics of palm oil waste under nitrogen and air atmosphere in TGA-FTIR with a complementary use of model-free and model-fitting approaches[J].Journal of Analytical and Applied Pyrolysis,2018,134:12.
-
[19]
张颖璞,李桂珍,黄朝章,等.不同产地烟叶的热解反应动力学研究[J].轻工学报,2018,33(2):55.
-
[20]
MA Z Q,SUN Q F,YE J W,et al.Study on the thermal degradation behaviors and kinetics of alkali lignin for production of phenolic-rich bio-oil using TGA-FTIR and Py-GC/MS[J].Journal of Analytical and Applied Pyrolysis,2016,117:116.
-
[1]
-
点击查看大图
计量
- PDF下载量: 42
- 文章访问数: 2233
- 引证文献数: 0
下载:
