JOURNAL OF LIGHT INDUSTRY

CN 41-1437/TS  ISSN 2096-1553

烟草在燃料制备领域的研究现状与展望

王金棒 ,  池哲翔 ,  李源源 ,  邱纪青 ,  汪志波 ,  张渝婕 ,  王永胜 ,  周雅宁

downloadPDF
王金棒, 池哲翔, 李源源, 等. 烟草在燃料制备领域的研究现状与展望[J]. 轻工学报, 2023, 38(6): 118-126. doi: 10.12187/2023.06.015
引用本文: 王金棒, 池哲翔, 李源源, 等. 烟草在燃料制备领域的研究现状与展望[J]. 轻工学报, 2023, 38(6): 118-126. doi: 10.12187/2023.06.015
shu
WANG Jinbang, CHI Zhexiang, LI Yuanyuan, et al. Research status and prospects of tobacco in the field of fuel preparation[J]. Journal of Light Industry, 2023, 38(6): 118-126. doi: 10.12187/2023.06.015
Citation: WANG Jinbang, CHI Zhexiang, LI Yuanyuan, et al. Research status and prospects of tobacco in the field of fuel preparation[J]. Journal of Light Industry, 2023, 38(6): 118-126. doi: 10.12187/2023.06.015
shu

烟草在燃料制备领域的研究现状与展望

  • 1. 中国烟草总公司郑州烟草研究院, 河南 郑州 450001;

  • 2. 国家烟草专卖局, 北京 100045;

  • 3. 中国烟草总公司职工进修学院, 河南 郑州 450008;

  • 4. 河北中烟工业有限责任公司 技术中心, 河北 石家庄 050051

    • 作者简介: 王金棒(1987-),男,河南省周口市人,中国烟草总公司郑州烟草研究院高级工程师,博士,主要研究方向为烟草产业技术预见、科技政策、创新管理。E-mail:wangjinbangok@126.com;

  • 基金项目: 国家烟草专卖局、中国烟草总公司首席科学家创新专项项目（602022CK0550）；国家烟草专卖局重点研发项目（110202102048；110202102051）

  • 中图分类号: TS49

Research status and prospects of tobacco in the field of fuel preparation

  • 1. Zhengzhou Tobacco Research Institute of CNTC, Zhengzhou 450001, China;

  • 2. State Tobacco Monopoly Bureau, Beijing 100045, China;

  • 3. Staff Development Institute of CNTC, Zhengzhou 450008, China;

  • 4. Technology center, China Tobacco Hebei Industrial Co., Ltd., Shijiazhuang 050051, China

  • Received Date: 2023-04-15
    Accepted Date: 2023-07-05

    CLC number: TS49

  • 摘要: 针对烟草生产及加工过程中产生的大量烟草废弃物所带来的环境污染和资源浪费的问解，从燃料存在形态的视角对烟草及其废弃物的燃料化利用现状进行梳理，指出：固体燃料制备简单、使用方便，但对设备的要求较高，其中烟草原料炭化成型燃料更易于运输存储、清洁环保，且燃烧残渣可进行二次利用。液体燃料制备技术较为成熟，直接提取法操作简单，但收率取决于烟草原料中油脂的固有含量，对烟草品种要求较高；热化学转化法耗能高，但创新空间较大，液态燃料的化学组成可调，发展潜力较大；发酵法产品单一，主要是乙醇，效率不高，整个技术链条中可规模应用的原料预处理技术尚未取得突破。气体燃料尚处于探索研发阶段，能耗高、收率偏低，技术经济性欠佳。未来可在烟草炭化成型、烟草发酵制备燃料乙醇、烟草催化热解，以及靶向能源用途烟草新品种的培育等方面进行深入系统研究，以进一步推动烟草多用途的产业化发展。
    Abstract: In order to avoid environmental pollution and resource waste produced during the production and processing of tobacco, this paper systematically reviewed the current status of fuel utilization of tobacco and its wastes and showed that:The preparation method of tobacco solid fuel was simple and convenient, but the requirements for equipment were high. Among them, tobacco briquette charcoal was more easily transported and stored, clean and environmentally friendly, furthermore, the combustion residue could also be used for secondary utilization in agriculture.The preparation method of liquid fuel preparation was relatively mature. The operation of the direct extraction technology was simple, but the bio-oil yield depended on the inherent fat content in tobacco raw materials. Therofore, it required higher requirements for tobacco varieties. The thermal chemical conversion method belonged to a chemical process with high energy consumption, but there is a large space for innovation with regard to the preparation method. The chemical composition of liquid fuels could be adjusted, having a huge development potential. The fermentation method produced a single product, mainly ethanol, with low efficiency at present. There has been no breakthrough in the pretreatment technology for scalable application of tobacco raw materials throughout the entire technical chain.The preparation method of gaseous fuel was still in the exploration stage, with high energy consumption and low yield. The tech-economic feasibility was poor. In the future, much more attention should be paid on tobacco briquette charcoal, tobacco fermentation for fuel ethanol production, tobacco catalytic pyrolysis for liquid fuel, as well as the cultivation of novel tobacco varieties targeted towards specific energy purpose. This will further promote the industrialized development of multiple purposes of tobacco.
    1. [1]

      王金棒, 贾楠, 汪志波, 等.烟草主要废弃物在多孔材料领域的研究进展[J].烟草科技, 2020, 53(12):96-105.

    2. [2]

      王金棒, 胡斌.烟草多用途技术与应用[M].郑州:郑州大学出版社, 2021.

    3. [3]

      陈振国.典型烟草废弃物热转化的机理研究及应用[D].武汉:华中科技大学, 2018.

    4. [4]

      林燕辉.烟秆生物质炭化与成型燃料制备及性能表征[D].杭州:浙江大学, 2015.

    5. [5]

      侯家萍, 王闻, 张蕾欣, 等.现代生物质能源技术体系及其产业化应用态势[J].现代化工, 2022, 42(5):7-13.

    6. [6]

      张得政, 张霞, 杨飞, 等.菌苞、木屑和烟秆颗粒燃料成型特性研究[J].农机化研究, 2017, 39(10):241-245.

    7. [7]

      宋春宇, 张体高, 朱晋熙, 等.烟秆秸秆压块在烟叶烘烤中的应用研究初报[J].湖南农业科学, 2016(3):82-84.

    8. [8]

      WANG L, FAN Y K, HE F, et al.Screening and testing of anti-slagging agents for tobacco-stalk-based biomass pellet fuel for tobacco curing[J].Processes, 2022, 10(9):1690.

    9. [9]

      莫静之.烟杆生物质燃料在烟叶烘烤中的应用研究[D].长沙:湖南农业大学, 2019.

    10. [10]

      CAI J X, LI B, CHEN C Y, et al.Hydrothermal carbonization of tobacco stalk for fuel application[J].Bioresource Technology, 2016, 220:305-311.

    11. [11]

      苟文涛, 王晓剑, 钟俊周, 等.不同配方生物质燃料物理特性与燃烧特性研究[J].安徽农业科学, 2018, 46(24):177-181
      , 223.

    12. [12]

      WANG X F, XU G Z, ZHANG B L, et al.Application of tobacco stems briquetting in tobacco flue-curing in rural area of China[J].International Journal of Agricultural & Biological Engineering, 2015, 8(6):84-88.

    13. [13]

      廖稷邦, 刘迎春, 陈鹏飞, 等.烟杆与配煤混燃特性及协同作用研究[J].煤炭技术, 2021, 40(9):200-203.

    14. [14]

      CONG K L, HAN F, ZHANG Y G, et al.The investigation of co-combustion characteristics of tobacco stalk and low rank coal using a macro-TGA[J].Fuel, 2019, 237:126-132.

    15. [15]

      谭方利, 樊士军, 董艳辉, 等.生物质压块燃料及煤炭燃料在烟叶烘烤中的应用效果对比研究[J].现代农业科技, 2014(10):201, 209.

    16. [16]

      饶月, 刘芮, 杨飞, 等.烟秆和木屑生物质颗粒燃料成型工艺参数优化[J].可再生能源, 2019, 37(5):650-655.

    17. [17]

      温丽娜, 陶琼, 欧阳进, 等.农林生物质原料热值比较及烟杆-玉米杆生物质燃料优化配方研究[J].湖南农业科学, 2016(1):43-46.

    18. [18]

      陈晶铃.烟杆裂解及微波膨化的研究[D].淮南:安徽理工大学, 2009.

    19. [19]

      BARLA F G, KUMAR S.Tobacco biomass as a source of advanced biofuels[J].Biofuels, 2019, 10(3):335-346.

    20. [20]

      ALAGIC S, STANCIC I, PALIC R, et al.Chemical composition of the supercritical CO2 extracts of the Yaka, Prilep and Otlja tobaccos[J].Journal of Essential Oil Research, 2006, 18(2):185-188.

    21. [21]

      ANDRIANOV V, BORISJUK N, POGREBNYAK N, et al.Tobacco as a production platform for biofuel:Overexpression of Arabidopsis DGAT and LEC2 genes increases accumulation and shifts the composition of lipids in green biomass[J].Plant Biotechnology Journal, 2010, 8(3):277-287.

    22. [22]

      FATICA A, DI LUCIA F, MARINO S, et al.Study on analytical characteristics of Nicotiana tabacum L., cv.Solaris biomass for potential uses in nutrition and biomethane production[J].Scientific Reports, 2019, 9(1):16828.

    23. [23]

      陈冠益, 马文超, 颜蓓蓓, 等.生物质废物资源综合利用技术[M].北京:化学工业出版社, 2015.

    24. [24]

      PVTVN A E, ÖNAL E, UZUN B B, et al.Comparison between the "slow" and "fast" pyrolysis of tobacco residue[J].Industrial Crops and Products, 2007, 26(3):307-314.

    25. [25]

      BOOKER C J, BEDMUTHA R, SCOTT I M, et al.Bioenergy Ⅱ:Characterization of the pesticide properties of tobacco bio-oil[J].International Journal of Chemical Reactor Engineering, 2010, 8:A26.

    26. [26]

      BOOKER C J, BEDMUTHA R, VOGEL T, et al.Experimental investigations into the insecticidal, fungicidal, and bactericidal properties of pyrolysis bio-oil from tobacco leaves using a fluidized bed pilot plant[J].Industrial & Engineering Chemistry Research, 2010, 49(20):10074-10079.

    27. [27]

      YAN B C, ZHANG S P, CHEN W B, et al.Pyrolysis of tobacco wastes for bio-oil with aroma compounds[J].Journal of Analytical and Applied Pyrolysis, 2018, 136:248-254.

    28. [28]

      STREZOV V, POPOVIC E, FILKOSKI R V, et al.Assessment of the thermal processing behavior of tobacco waste[J].Energy & Fuels, 2012, 26(9):5930-5935.

    29. [29]

      ONOREVOLI B, DA SILVA MACIEL G P, MACHADO M E, et al.Characterization of feedstock and biochar from energetic tobacco seed waste pyrolysis and potential application of biochar as an adsorbent[J].Journal of Environmental Chemical Engineering, 2018, 6(1):1279-1287.

    30. [30]

      HOSSAIN M M, SCOTT I M, BERRUTI F, et al.A two-dimensional pyrolysis process to concentrate nicotine during tobacco leaf bio-oil production[J].Industrial Crops and Products, 2018, 124:136-141.

    31. [31]

      HOSSAIN M M, SCOTT I M, BERRUTI F, et al.Optimizing pyrolysis reactor operating conditions to increase nicotine recovery from tobacco leaves[J].Journal of Analytical and Applied Pyrolysis, 2015, 112:80-87.

    32. [32]

      HOSSAIN M M, SCOTT I M, BERRUTI F, et al.Application of 1D and 2D MFR reactor technology for the isolation of insecticidal and anti-microbial properties from pyrolysis bio-oils[J].Journal of Environmental Science and Health, Part B(Pesticides, Food Contaminants, and Agricultural Wastes), 2016, 51(12):860-867.

    33. [33]

      HOSSAIN M M, SCOTT I M, BERRUTI F, et al.Application of novel pyrolysis reactor technology to concentrate bio-oil components with antioxidant activity from tobacco, tomato and coffee ground biomass[J].Waste and Biomass Valorization, 2018, 9(9):1607-1617.

    34. [34]

      AKALIN M K, KARAGÖZ S.Pyrolysis of tobacco residue.Part 2:Catalytic[J].BioResources, 2011, 6(2):1773-1805.

    35. [35]

      CARDOSO C R, ATAÍDE C H.Micropyrolysis of tobacco powder at 500℃:Influence of ZnCl2 and MgCl2 contents on the generation of products[J].Chemical Engineering Communications, 2015, 202(4):484-492.

    36. [36]

      CARDOSO C R, ATAÍDE C H.Analytical pyrolysis of tobacco residue:Effect of temperature and inorganic additives[J].Journal of Analytical and Applied Pyrolysis, 2013, 99:49-57.

    37. [37]

      SOPHANODORN K, UNPAPROM Y, WHANGCHAI K, et al.Environmental management and valorization of cultivated tobacco stalks by combined pretreatment for potential bioethanol production[J].Biomass Conversion and Biorefinery, 2022, 12(5):1627-1637.

    38. [38]

      吴创之, 马隆龙.生物质能现代化利用技术[M].北京:化学工业出版社, 2003.

    39. [39]

      MARTÍN C, FERNÁNDEZ T, GARCÍA R, et al.Preparation of hydrolysates from tobacco stalks and ethanolic fermentation by Saccharomyces cerevisiae[J].World Journal of Microbiology and Biotechnology, 2002, 18(9):857-862.

    40. [40]

      MARTÍN C, FERNÁNDEZ T, GARCÍA A, et al.Wet oxidation pretreatment of tobacco stalks and orange waste for bioethanol production.Preliminary results[J].Cellulose Chemistry and Technology, 2008, 42(7/8):429-434.

    41. [41]

      谢兆钟, 李汉民, 吴进德.利用烟草废弃物生产酒精的方法:200810070873[P].2008-02-05.

    42. [42]

      谢丽萍, 赵晓祥, 杨虹蛟, 等.烟草下脚料发酵制取乙醇[J].环境工程学报, 2010, 4:1417-1420.

    43. [43]

      SARBISHEI S, GOSHADROU A, HATAMIPOUR M S.Mild sodium hydroxide pretreatment of tobacco product waste to enable efficient bioethanol production by separate hydrolysis and fermentation[J].Biomass Conversion and Biorefinery, 2021, 11(6):2963-2973.

    44. [44]

      SCIENCE DAILY.Genetically modified tobacco plants are viable for producing biofuels[EB/OL].(2013-10-14)[2023-04-15].https://www.sciencedaily.com/releases/2013/10/131014094119.htm.

    45. [45]

      FARRAN I, MILLAN A F S, ANCIN M, et al.Increased bioethanol production from commercial tobacco cultivars overexpressing thioredoxin f grown under field conditions[J].Molecular Breeding, 2014, 34(2):457-469.

    46. [46]

      邱志丹, 连宇昌, 卢雨, 等.烟秆与木屑配方生物质燃料在烟叶烘烤中的应用[J].福建农林大学学报(自然科学版), 2021, 50:10-15.

    47. [47]

      杨益, 烟草废弃物热解和气化的实验及机理研究[D].武汉:华中科技大学, 2012.

    48. [48]

      ENCINAR J M, BELTRÁN F J, GONZÁLEZ J F, et al.Pyrolysis of maize, sunflower, grape and tobacco residues[J].Journal of Chemical Technology and Biotechnology, 1997, 70(4):400-410.

    49. [49]

      AYAS N, KARADENIZ S.Hydrogen from tobacco waste[C]//Proceedings of the 2nd International Conference Sustainable and Renewable Energy Engineering.Hiroshima:IEEE, 2017.

    50. [50]

      KLAAS M, GREENHALF C, FERRANTE L, et al.Optimisation of hydrogen production by steam reforming of chars derived from lumber and agricultural residues[J].International Journal of Hydrogen Energy, 2015, 40(9):3642-3647.

    51. [51]

      田甜, 李清海, 李文妮, 等.温度和水蒸气流量对烟秆高温气化的影响[J].环境工程学报, 2016, 10(4):1973-1978.

    52. [52]

      MADENOGLU T G, KURT S, SAGLAM M, et al.Hydrogen production from some agricultural residues by catalytic subcritical and supercritical water gasification[J].The Journal of Supercritical Fluids, 2012, 67:22-28.

    53. [53]

      MEHER K K, PANCHWAGH A M, RANGRASS S, et al.Biomethanation of tobacco waste[J].Environmental Pollution, 1995, 90(2):199-202.

    54. [54]

      陈智远, 姚建刚.秸秆厌氧干发酵产沼气的研究[J].农业工程技术(新能源产业), 2009(10):24-26.

    55. [55]

      GONZÁLEZ-GONZÁLEZ A, CUADROS F.Optimal and cost-effective industrial biomethanation of tobacco[J].Renewable Energy, 2014, 63:280-285.

    56. [56]

      WANG C H, LI L Q, CHEN R F, et al.Thermal conversion of tobacco stem into gaseous products[J].Journal of Thermal Analysis and Calorimetry, 2019, 137(3):811-823.

    1. [1]

      池哲翔 , 廖敏 , 史尚 , 李声毅 , 廖芸 , 丁冬 . 国外烟草活性成分提取及纤维材料利用现状与展望. 轻工学报, 2024, 0(0): -.

  • 加载中
WeChat 点击查看大图
计量
  • PDF下载量:  20
  • 文章访问数:  952
  • 引证文献数: 0
文章相关
  • 收稿日期:  2023-04-15
  • 修回日期:  2023-07-05
通讯作者: 陈斌, bchen63@163.com
  • 1. 

    沈阳化工大学材料科学与工程学院 沈阳 110142

  1. 本站搜索
  2. 百度学术搜索
  3. 万方数据库搜索
  4. CNKI搜索
王金棒, 池哲翔, 李源源, 等. 烟草在燃料制备领域的研究现状与展望[J]. 轻工学报, 2023, 38(6): 118-126. doi: 10.12187/2023.06.015
引用本文: 王金棒, 池哲翔, 李源源, 等. 烟草在燃料制备领域的研究现状与展望[J]. 轻工学报, 2023, 38(6): 118-126. doi: 10.12187/2023.06.015
shu
WANG Jinbang, CHI Zhexiang, LI Yuanyuan, et al. Research status and prospects of tobacco in the field of fuel preparation[J]. Journal of Light Industry, 2023, 38(6): 118-126. doi: 10.12187/2023.06.015
Citation: WANG Jinbang, CHI Zhexiang, LI Yuanyuan, et al. Research status and prospects of tobacco in the field of fuel preparation[J]. Journal of Light Industry, 2023, 38(6): 118-126. doi: 10.12187/2023.06.015
shu

烟草在燃料制备领域的研究现状与展望

    作者简介:王金棒(1987-),男,河南省周口市人,中国烟草总公司郑州烟草研究院高级工程师,博士,主要研究方向为烟草产业技术预见、科技政策、创新管理。E-mail:wangjinbangok@126.com
  • 1. 中国烟草总公司郑州烟草研究院, 河南 郑州 450001;
  • 2. 国家烟草专卖局, 北京 100045;
  • 3. 中国烟草总公司职工进修学院, 河南 郑州 450008;
  • 4. 河北中烟工业有限责任公司 技术中心, 河北 石家庄 050051
  • 收稿日期: 2023-04-15
  • 录用日期: 2023-07-05
基金项目:  国家烟草专卖局、中国烟草总公司首席科学家创新专项项目（602022CK0550）；国家烟草专卖局重点研发项目（110202102048；110202102051）

摘要: 针对烟草生产及加工过程中产生的大量烟草废弃物所带来的环境污染和资源浪费的问解，从燃料存在形态的视角对烟草及其废弃物的燃料化利用现状进行梳理，指出：固体燃料制备简单、使用方便，但对设备的要求较高，其中烟草原料炭化成型燃料更易于运输存储、清洁环保，且燃烧残渣可进行二次利用。液体燃料制备技术较为成熟，直接提取法操作简单，但收率取决于烟草原料中油脂的固有含量，对烟草品种要求较高；热化学转化法耗能高，但创新空间较大，液态燃料的化学组成可调，发展潜力较大；发酵法产品单一，主要是乙醇，效率不高，整个技术链条中可规模应用的原料预处理技术尚未取得突破。气体燃料尚处于探索研发阶段，能耗高、收率偏低，技术经济性欠佳。未来可在烟草炭化成型、烟草发酵制备燃料乙醇、烟草催化热解，以及靶向能源用途烟草新品种的培育等方面进行深入系统研究，以进一步推动烟草多用途的产业化发展。

English Abstract

参考文献 (56) 相关文章 (1)

目录

/

返回文章

网站版权 © 轻工学报编辑部

地址：河南省郑州市科学大道136号邮编：450001

本系统由北京仁和汇智信息技术有限公司开发 技术支持： info@rhhz.net