新型保润剂丙二醇吡咯酯的制备及其对再造烟叶保润效果研究
Preparation of a novel moisturizing agent propylene glycol pyrrolide and its moisturizing effect on reconstructed tobacco leaves
-
摘要: 为克服传统保润剂丙二醇在加热烟草制品中吸湿性过强的缺点,制备了一种新型保润剂丙二醇吡咯酯,并利用热重-微商热重-差示扫描量热法、热裂解气相色谱/质谱和低场核磁共振技术考查其热行为及其在再造烟叶中的保润效果。结果表明:丙二醇吡咯酯的热失重区间为149.9~400.0 ℃,在298.7 ℃时质量损失率达最大(77.39 %);在200 ℃、300 ℃和350 ℃下的主要裂解产物为吡咯酸和丙二醇,其中丙二醇可以起到协调和降低烟气干燥感的作用;在低湿环境下添加丙二醇吡咯酯的再造烟叶丝保润能力高于空白组,但低于丙二醇组;丙二醇组、丙二醇吡咯酯组和空白组中再造烟叶丝内部结合水占比分别为75 %、70 %、68 %,即丙二醇吡咯酯可以降低再造烟叶丝的强吸湿性,同时保持一定的保润能力。Abstract: To overcome the disadvantage of strong moisture absorption of traditional moisturizing agent propylene glycol in heated tobacco products, a new type of moisturizing agent propylene glycol pyrrole ester was prepared, and its thermal behavior and moisture retention effect in reconstituted tobacco leaves were investigated by thermogravimetric-derivative thermogravimetry-differential scanning calorimetry, pyrolysis gas chromatography/mass spectrometry and low-field nuclear magnetic resonance imaging. The results showed that:the thermal weight loss interval of propylene glycol pyrrole ester was from 149.9 ℃ to 400.0 ℃, and the maximum weight loss rate 77.39 % reached at 298.7 ℃. Propylene glycol pyrrole ester was subjected to thermal cracking at 200 ℃, 300 ℃ and 350 ℃, and it mainly could crack and decompose to release pyrrolidic acid and propylene glycol, among which propylene glycol could harmonise and reduce the sense of dryness of the tobacco. The moisture retention ability of reconstituted tobacco leaves added with propylene glycol pyrrole ester in low humidity environment was higher than that of the blank group, but lower than that of the propylene glycol group; The area of bound water inside the reconstituted tobacco leaves in a low humidity environment of propylene glycol group, propylene glycol pyrrole ester group and blank group was 75 %, 70 %, and 68 %, respectively. Propylene glycol pyrrole ester could reduce the strong moisture absorption of reconstituted tobacco leaves while maintaining a certain degree of moisture retention.
-
-
[1]
LACHENMEIER D W,ANDERSON P,REHM J.Heat-not-burn tobacco products:The devil in disguise or a considerable risk reduction?[J].International Journal of Alcohol and Drug Research,2018,7(2):8-11.
-
[2]
TOMASZ J,JASON A,SIMONE S,et al.Assessment of tobacco heating product THP1.0.Part 5:Invitro dosimetric and cytotoxic assessment[J].Regulatory Toxicology and Pharmacology,2018,93:52-61.
-
[3]
谢剑平.卷烟危害性评价原理与方法[M].北京:化学工业出版社,2009.
-
[4]
杨焱.烟草的危害,流行特点及控制策略[J].中国健康教育,2006,22(5):387-389.
-
[5]
SIMONAVICIUS E,MCNEILL A,SHAHAB L,et al.Heat-not-burn tobacco products:A systematic literature review[J].Tobacco Control, 2019,28(5):582-594.
-
[6]
TSOU H H,WANG P H,TING T H,et al.Effect of heated tobacco products and traditional cigarettes on pulmonary toxicity and SARS-CoV-2-induced lung injury[J].Toxicology,2022,479:153318.
-
[7]
ZHOU C F,QIAN P,MENG J,et al.Effect of glycerol and sorbitol on the properties of dough and white bread[J].Cereal Chemistry,2016,93(2):196-200.
-
[8]
HECK J D,GAWORSKI C L,RAJENDRAN N,et al.Toxicologic evaluation of humectants added to cigarette tobacco:13-week smoke inhalation study of glycerin and propylene glycol in fischer 344 rats[J].Inhalation Toxicology,2002,14(11):1135-1152.
-
[9]
RAINEY C L,SHIFFLETT J R,GOODPASTER J V,et al.Quantitative analysis of humectants in tobacco products using gas chromatography (GC) with simultaneous mass spectrometry (MSD) and flame ionization detection (FID)[J].Contributions to Tobacco Research,2013,25(6):576-585.
-
[10]
ZHU M,WU K,ZHOU Y Z,et al.Prediction of cooling moisture content after cut tobacco drying process based on a particle swarm optimization-extreme learning machine algorithm[J].Mathematical Biosciences and Engineering,2021,18(3):2496-2507.
-
[11]
程向红,刘强,王根发,等.不同干燥强度对香料烟叶丝质量的影响[J].轻工学报,2022,37(2):59-64.
-
[12]
祁令凯,王建玲,姬小明,等.肉桂酸4-(4-乙酰基-5-甲基-2-吡咯基)-2',3',4'-三羟基丁酯的合成及其卷烟加香应用[J].精细化工,2013,30(5):539-543
,584. -
[13]
刘玉平,孙宝国,田红玉,等.含氮食用香料的概况[J].中国食品添加剂,2005(2):64-67.
-
[14]
MAGA J A.Pyrroles in foods[J].Journal of Agricultural and Food Chemistry,1981,29(4):691-694.
-
[15]
MESTDAGH F,DAVIDEK T,CHAUMONTEUIL M.The kinetics of coffee aroma extraction[J].Food Research International,2014,63:271-274.
-
[16]
陈芝飞,陈泽少,罗灿选,等.加热卷烟气溶胶中6种酯类单体香料转移行为研究[J].轻工学报,2022,37(3):58-64.
-
[17]
司晓喜,张凤梅,朱瑞芝,等.6种香料在加热条件下的释放迁移及对气溶胶理化特性的影响[J].轻工学报,2021,36(5):67-75.
-
[18]
FAN W P,CHU W J,TIAN H Y,et al.Synthesis and pyrolysis of two novel pyrrole ester flavor precursors[J].Journal of Heterocyclic Chemistry,2022,59(8):1397-1406.
-
[19]
张渝婕,郑松锦,钟良,等.低场核磁共振技术在烟草中的应用研究现状[J].河北农业科学,2019,23(3):96-99.
-
[20]
FAN W P,CHU W J,LI Y G,et al.Synthesis,characterization and thermal behavior of n-substituted pyrrole esters[J].Chemistry Select,2022,44(7):e202203722.
-
[21]
国家烟草专卖局.烟草及烟草制品试样的制备和水份测定烘箱法:YC/T 31-1996[S].北京:中国标准出版社,1996.
-
[22]
刘金云,赵瑜,傅见山,等.几种保润剂对卷烟烟气化学成分的影响[J].理化检验(化学分册),2013,49(6):738-742.
-
[23]
LIN C,CUI H P,WANG X J,et al.Regulating water binding capacity and improving porous carbohydrate matrix's humectant and moisture proof functions by mixture of sucrose ester and polygonatum sibiricum polysaccharide[J].International Journal of Biological Macromolecules,2020,147:667-674.
-
[24]
WANG J,JIN W H,HOU Y,et al.Chemical composition and moisture-absorption/retention ability of polysaccharides extracted from five algae[J].International Journal of Biological Macromolecules,2013,57:26-29.
-
[1]
-
点击查看大图
计量
- PDF下载量: 20
- 文章访问数: 1735
- 引证文献数: 0
下载:
