湿热处理过程中乙醇对粳米结构及性能的影响
Effect of ethanol on structures and properties of Japonica rice during heat-moisture treatment
-
摘要: 【目的】 提升粳米的食品加工适应性与应用价值。【方法】 采用湿热处理对粳米进行改性,研究湿热处理(水分质量分数25%)过程中,占水分质量分数分别为40%、80%和120%的乙醇对粳米结构(直链淀粉含量、形貌特征和结晶结构)及性能(糊化特性、蒸煮损失率和消化性能)的影响规律。【结果】 湿热处理能显著降低粳米中直链淀粉及A型结晶含量,促进V型结晶结构形成,提高粳米的热稳定性并降低其黏度和蒸煮损失率;乙醇的介入不会改变粳米的结晶类型,但会显著破坏其微观结构,降低A型结晶含量,提高直链淀粉及V型结晶含量。较低质量分数(40%~80%)的乙醇对粳米中A型结晶结构的破坏程度较大,可诱导形成更多的V型结晶,从而显著提高粳米的热稳定性,降低黏度和蒸煮损失率,并增加快消化淀粉含量;当乙醇质量分数提高至120%时,粳米中A型结晶含量没有明显变化,V型结晶含量减少,致使粳米的热稳定性减弱、黏度提高、蒸煮损失率和慢消化淀粉含量增加。【结论】 通过改变湿热处理过程中乙醇的质量分数可定向调控粳米结构与性能的变化。Abstract: 【Objective】 To improve the food processing adaptability and practical value of Japonica rice. 【Methods】 Heat-moisture treatment (moisture content: 25%) was used for the modification of Japonica rice. The effects of ethanol at 40%, 80%, and 120% of the moisture content on structural properties (amylose content, morphology, crystalline structure) and functional properties (pasting properties, cooking loss, digestibility) were systematically investigated. 【Results】 Heat-moisture treatment significantly reduced the amylose content and A-type crystallinity, while promoting the formation of V-type crystalline structures. This enhanced thermal stability and reduced viscosity and cooking loss. The addition of ethanol did not alter the crystalline structure type but induced microstructural disruption, reducing A-type crystallinity while increasing amylose content and V-type crystalline formation. Moderate ethanol concentrations (40%~80%) caused greater disruption of A-type structures and promoted V-type crystallization, thereby improving thermal stability and rapidly digestible starch content while decreasing viscosity and cooking loss. At 120% ethanol concentration, A-type crystallinity remained stable but V-type crystalline formation decreased, leading to reduced thermal stability, increased viscosity and cooking loss, and elevated slowly digestible starch content. 【Conclusion】 The structural and functional properties of Japonica rice can be precisely modulated by controlling ethanol concentrations during heat-moisture treatment.
-
Key words:
- Japonica rice /
- heat-moisture treatment /
- ethanol /
- structure /
- property
-
-
[1]
ZHANG W,LIU Y X,LUO X L,et al.Pasting,cooking,and digestible properties of Japonica rice with different amylose contents[J].International Journal of Food Properties,2022,25(1):936-947.
-
[2]
王宏伟,丁江涛,张艳艳,等.湿热处理对薏米淀粉聚集态结构及糊化特性的影响[J].食品科学,2020,41(17):111-117.
WANG H W,DING J T,ZHANG Y Y,et al.Impact of heat moisture treatment on the aggregation structure and pasting behavior of adlay starch[J].Food Science,2020,41(17):111-117. -
[3]
SCHAFRANSKI K,ITO V C,LACERDA L G.Impacts and potential applications:A review of the modification of starches by heat-moisture treatment (HMT)[J].Food Hydrocolloids,2021,117:106690.
-
[4]
HE H,ZHENG B,WANG H W,et al.Insights into the multi-scale structure and in vitro digestibility changes of rice starch-oleic acid/linoleic acid complex induced by heat-moisture treatment[J].Food Research International,2020,137:109612.
-
[5]
WANG H W,DING J T,XIAO N Y,et al.Insights into the hierarchical structure and digestibility of starch in heat-moisture treated adlay seeds[J].Food Chemistry,2020,318:126489.
-
[6]
LIN Z X,ZHANG R,WU Z T,et al.Prolonging heat-moisture treatment time at medium moisture content optimizes the quality attributes of cooked brown rice through starch structural alteration[J].International Journal of Biological Macromolecules,2024,279:135561.
-
[7]
中华人民共和国国家卫生健康委员会,国家市场监督管理总局.食品安全国家标准 食品添加剂使用标准:GB 2760—2024[S].北京:中国标准出版社,2024. National Health Commission of the People’s Republic of China,State Administration for Market Regulation.National food safety standard standards for the use of food additives:GB 2760—2024[S].Beijing:China Standards Press,2024.
-
[8]
ZHOU X,XING Y R,MENG T T,et al.Preparation of V-type cold water-swelling starch by ethanolic extrusion[J].Carbohydrate Polymers,2021,271:118400.
-
[9]
LU P,LI X X,JANASWAMY S,et al.Insights on the structure and digestibility of sweet potato starch:Effect of postharvest storage of sweet potato roots[J].International Journal of Biological Macromolecules,2020,145:694-700.
-
[10]
CHI C D,REN W W,YANG Y,et al.Starch ordered structures control starch reassembly behaviors during heat-moisture treatment for modulating its digestibility[J].Food Chemistry,2024,430:136966.
-
[11]
王艳,张煜松,刘兴丽,等.湿热处理对绿豆淀粉结构及理化特性的影响[J].轻工学报,2022,37(3):36-42.
WANG Y,ZHANG Y S,LIU X L,et al.Effect of heat moisture treatment on the structural and physicochemicalproperties of mung bean starch[J].Journal of Light Industry,2022,37(3):36-42. -
[12]
CHI C D,LI X X,LU P,et al.Dry heating and annealing treatment synergistically modulate starch structure and digestibility[J].International Journal of Biological Macromolecules,2019,137:554-561.
-
[13]
YANG X J,CHI C D,LIU X L,et al.Understanding the structural and digestion changes of starch in heat-moisture treated polished rice grains with varying amylose content[J].International Journal of Biological Macromolecules,2019,139:785-792.
-
[14]
APOSTOLIDIS E,MANDALA I.Modification of resistant starch nanoparticles using high-pressure homogenization treatment[J].Food Hydrocolloids,2020,103:105677.
-
[15]
WANG H W,ZHANG Y S,SU P P,et al.Insights into the aggregation structure and physicochemical properties of heat-moisture treated wheat starch and its associated effects on noodle quality[J].Journal of Cereal Science,2023,112:103704.
-
[16]
CHEN B Y,GUO Z B,ZENG S X,et al.Paste structure and rheological properties of lotus seed starch-glycerin monostearate complexes formed by high-pressure homogenization[J].Food Research International,2018,103:380-389.
-
[17]
CHI C D,LI X X,HUANG S X,et al.Basic principles in starch multi-scale structuration to mitigate digestibility:A review[J].Trends in Food Science and Technology,2021,109:154-168.
-
[1]
-
点击查看大图
计量
- PDF下载量: 4
- 文章访问数: 92
- 引证文献数: 0
下载:
