JOURNAL OF LIGHT INDUSTRY

CN 41-1437/TS  ISSN 2096-1553

基于离子液体的菌藻类胡萝卜素提取工艺研究

张志平 ,  宋洋洋 ,  王秋领 ,  王清福 ,  龚贵平 ,  付瑜锋 ,  陈高

downloadPDF
张志平, 宋洋洋, 王秋领, 等. 基于离子液体的菌藻类胡萝卜素提取工艺研究[J]. 轻工学报, 2024, 39(2): 19-27. doi: 10.12187/2024.02.003
引用本文: 张志平, 宋洋洋, 王秋领, 等. 基于离子液体的菌藻类胡萝卜素提取工艺研究[J]. 轻工学报, 2024, 39(2): 19-27. doi: 10.12187/2024.02.003
shu
ZHANG Zhiping, SONG Yangyang, WANG Qiuling, et al. Research on extraction process of carotenoids from yeasts and algae based on ionic liquid[J]. Journal of Light Industry, 2024, 39(2): 19-27. doi: 10.12187/2024.02.003
Citation: ZHANG Zhiping, SONG Yangyang, WANG Qiuling, et al. Research on extraction process of carotenoids from yeasts and algae based on ionic liquid[J]. Journal of Light Industry, 2024, 39(2): 19-27. doi: 10.12187/2024.02.003
shu

基于离子液体的菌藻类胡萝卜素提取工艺研究

  • 1. 郑州轻工业大学 食品与生物工程学院, 河南 郑州 450001;

  • 2. 河南中烟工业有限责任公司 技术中心, 河南 郑州 450003;

  • 3. 农业农村部成都沼气科学研究所, 四川 成都 610042;

  • 4. 山东省农业科学研究院, 山东 济南 250100

    • 作者简介: 张志平(1981-),男,河南省安阳县人,郑州轻工业大学副教授,博士,主要研究方向为生物质资源化利用。E-mail:zzp@zzuli.edu.cn;

  • 基金项目: 河南省科技攻关项目(212102310077)
    中原科技创新领军人才项目(224200510017)

  • 中图分类号: TS202.3

Research on extraction process of carotenoids from yeasts and algae based on ionic liquid

  • 1. College of Food and Bioengineering, Zhengzhou University of Light Industry, Zhengzhou 450001, China;

  • 2. Technology Center, China Tobacco Henan Industrial Co., Ltd., Zhengzhou 450003, China;

  • 3. Biogas Institute of Ministry of Agriculture and Rural Affairs, Chengdu 610042, China;

  • 4. Shandong Academy of Agricultural Science, Jinan 250100, China

  • Received Date: 2023-10-24
    Accepted Date: 2024-02-24

    CLC number: TS202.3

  • 摘要: 以含有粘红酵母和小球藻的菌藻泥为原料,通过单因素试验和响应面试验对菌藻类胡萝卜素提取工艺进行优化,并考查菌藻类胡萝卜素的体外抗氧化活性。结果表明:菌藻破壁的最优离子液体为1-丁基-3-甲基咪唑氯化物(BMIMCl),菌藻类胡萝卜素的最佳提取工艺为离子液体浓度1 mol/L、预处理温度53 ℃和预处理时间57 min,在该条件下,菌藻类胡萝卜素的提取量为1.311 mg/g;当质量浓度为30 μg/mL时,菌藻类胡萝卜素对DPPH自由基、·OH自由基和ABTS+自由基的清除率分别为82.3 %、37.6 %、和86.8 %,还原力为0.289,表现出较好的抗氧化活性。因此,经BMIMCl破壁处理后,从菌藻泥中提取的类胡萝卜素含量更高,抗氧化活性也较好。
    Abstract: Using Rhodotorula glutinis and Chlorella vularis sludge as raw material, the extraction process of carotenoids from yeast and algae was optimized through single factor and response experiments, and the in vitro antioxidant activity of carotenoids from yeast and algae was investigated. The results showed that the optimal ionic liquid for yeast and algal wall breaking was 1-butyl-3-methylimidazole chloride (BMIMCl), and the optimal extraction process for carotene from yeast and algal sludge was 1 mol/L ionic liquid concentration, pre-treatment temperature of 53 ℃, and pre-treatment time of 57 min. Under this condition, the extraction amount of carotene from yeast and algae was 1.311 mg/g. When the mass concentration was 30 μg/mL, the scavenging rates of DPPH free radical, ·OH free radical and ABTS+ free radical were 82.3 %, 37.6 % and 86.8 %, respectively, and the reducing power was 0.289, showing good antioxidant activity. The yeast and algal sludge treated with BMIMCl had a higher content of extracted carotenoids and better antioxidant activity.
    1. [1]

      朱丽花,马延琴,纪彦宇,等.产类胡萝卜素酵母菌的筛选及色素稳定性分析[J].中国酿造,2021,40(9):139-144.

    2. [2]

      SAINI R K,KEUM Y S.Progress in microbial carotenoids production[J].Indian Journal of Microbiology,2017,57(1):129-130.

    3. [3]

      张志平,段乃心,魏湘楠,等.基于光胁迫粘红酵母合成高值化类胡萝卜素发酵条件优化[J].轻工学报,2022,37(4):10-17.

    4. [4]

      MESQUITA L D M,MARTINS M,PISANI L P,et al.Insights on the use of alternative solvents and technologies to recover bio-based food pigments[J].Comprehensive Reviews in Food Science and Food Safety,2021,20(1):787-818.

    5. [5]

      MUSSAGY C U,KHAN S,KOT A M.Current developments on the application of microbial carotenoids as an alternative to synthetic pigments[J].Comprehensive Reviews in Food Science and Food Safety,2021,62(25):6932-6946.

    6. [6]

      马浩.菌藻共生好氧颗粒污泥系统构建及强化脱氮机制研究[D].西安:西安理工大学,2023.

    7. [7]

      李旻昊.菌藻互利共生关系以及可生物降解材料对其影响[J].山东化工,2021,50(5):275-279.

    8. [8]

      鄢子鹏,郑梦启,王成业,等.混合营养脱氮在低C/N工业废水处理中的研究进展[J].化工进展,2023,42(12):6567-6575.

    9. [9]

      李盈盈.菌藻共生系统(BASS)的构建及处理海产养殖废水的研究[D].广州:广州大学,2023.

    10. [10]

      POULHAZAN A,WIDANAGE M C D,MUSZYN A,et al.Identification and quantification of glycans in whole cells:Architecture of microalgal polysaccharides described by solid-state nuclear magnetic resonance[J].Journal of the American Chemical Society,2021,143(46):19374-19388.

    11. [11]

      ADAM F,ABERT-VIAN M,PELTIER G,et al. "Solvent-free" ultrasound-assisted extraction of lipids from fresh microalgae cells:A green,clean and scalable process[J].Bioresource Technology,2012,114:457-465.

    12. [12]

      MARTINS P L G,DE ROSSO V V.Thermal and light stabilities and antioxidant activity of carotenoids from tomatoes extracted using an ultrasound-assisted completely solvent-free method[J].Food Research International,2016,82:156-164.

    13. [13]

      RICHARD P,SWATLOSKI S K,SPEAR J D,et al. Dissolution of celllulose with lonic liquids[J].Journal of the American Chemical Society,2002,124(18):4974-4975.

    14. [14]

      MEENATCHI B,RENUGA V,MANIKANDAN A.Cellulose dissolution and regeneration using various imidazolium based protic ionic liquids[J].Journal of Molecular Liquids,2017,238:582-588.

    15. [15]

      ZHANG H,WU J,ZHANG J,et al.1-Allyl-3-methylimidazolium chloride room temperature ionic liquid:A new and powerful nonderivatizing solvent for cellulose[J].Macromolecules,2005,38(20):8272-8277.

    16. [16]

      STEFANESCU C,DALY W H,NEGULESCU I I.Functionalization of cellulose and chitosan in ionic liquids[J].Cellulose Chemistry and Technology,2020,54(9/10):857-868.

    17. [17]

      WANG J L,WEI L G,MA Y C,et al.Collagen/cellulose hydrogel beads reconstituted from ionic liquid solution for Cu (Ⅱ) adsorption[J].Carbohydrate Polymers,2013,98(1):736-743.

    18. [18]

      MUSSAGY C U,FARIAS F O,BILA N M,et al.Recovery of β-carotene and astaxanthin from Phaffia rhodozyma biomass using aqueous solutions of cholinium-based ionic liquids[J].Separation and Purfication Technology,2022,290:120852.

    19. [19]

      段志航,赵彩云,代博,等.紫色姜总黄酮提取工艺优化及其抗氧化作用研究[J].食品工业,2023,44(10):30-36.

    20. [20]

      钟淑娟,杨欣,李静,等.杜仲不同部位总黄酮含量及抗氧化活性研究[J].中国药房,2017,28(13):1787-1790.

    21. [21]

      曾桥,韦承伯,韩国锋,等.桑叶茯砖茶总黄酮提取工艺优化及抗氧化活性[J].食品科技,2018,43(6):221-230.

    22. [22]

      熊春华,周苏果,沈忱,等.响应面法优化提取菊米黄酮及抗氧化活性研究[J].中国食品学报,2014,14(7):118-123.

    23. [23]

      WANG X,XU W L,LIU Q Q,et al.Microwave-assisted ionic liquid microextraction combined with high performance liquid chromatography for the determination of naphthoquinones from Arnebia euchroma(Royle) Johnst[J].Journal of Liquid Chromatography&Related Technologies,2019,42(19/20):638-647.

    24. [24]

      BRANDT A,GRASVIK J,HALLETT J P,et al.Deconstruction of lignocellulosic biomass with ionic liquids[J].Green Chemistry,2013,15(3):550-583.

    25. [25]

      HIRANVARACHAT B,DEVAHASTIN S.Enhancement of microwave-assisted extraction via intermittent radiation:extraction of carotenoids from carrot peels[J].Journal of Food Engineering,2014,126:17-26.

    26. [26]

      DEY S,RATHOD V K.Ultrasound assisted extraction of β-carotene from Spirulina platensis[J].Ultrasonics Sonochemistry,2013,20(1):271-276.

    27. [27]

      肖勇生,周杰,钟红英,等.响应面法优化紫山药葛根复合饮品发酵工艺[J].食品工业,2023,44(10):36-41.

    1. [1]

      池哲翔 , 廖敏 , 史尚 , 李声毅 , 廖芸 , 丁冬 . 国外烟草活性成分提取及纤维材料利用现状与展望. 轻工学报, 2024, 0(0): -.

    2. [2]

      吕金羚 , 傅亮 , 陈永生 . 红茶-花生蛋白复合饮品工艺优化及其营养特性研究. 轻工学报, 2024, 0(0): -.

    3. [3]

      吕金羚 , 傅亮 , 陈永生 . 红茶-花生蛋白复合饮品工艺优化及其营养特性研究. 轻工学报, 2024, 39(5): 9-17. doi: 10.12187/2024.05.002

    4. [4]

      胡新楠 , 朱成凯 , 胡中泽 , 纪执立 , 金伟平 , 郭城 , 沈汪洋 . 复配比对明胶-羟丙基甲基纤维素双水相体系微观结构和流变特性的影响. 轻工学报, 2024, 0(0): -.

  • 加载中
WeChat 点击查看大图
计量
  • PDF下载量:  23
  • 文章访问数:  2761
  • 引证文献数: 0
文章相关
  • 收稿日期:  2023-10-24
  • 修回日期:  2024-02-24
通讯作者: 陈斌, bchen63@163.com
  • 1. 

    沈阳化工大学材料科学与工程学院 沈阳 110142

  1. 本站搜索
  2. 百度学术搜索
  3. 万方数据库搜索
  4. CNKI搜索
张志平, 宋洋洋, 王秋领, 等. 基于离子液体的菌藻类胡萝卜素提取工艺研究[J]. 轻工学报, 2024, 39(2): 19-27. doi: 10.12187/2024.02.003
引用本文: 张志平, 宋洋洋, 王秋领, 等. 基于离子液体的菌藻类胡萝卜素提取工艺研究[J]. 轻工学报, 2024, 39(2): 19-27. doi: 10.12187/2024.02.003
shu
ZHANG Zhiping, SONG Yangyang, WANG Qiuling, et al. Research on extraction process of carotenoids from yeasts and algae based on ionic liquid[J]. Journal of Light Industry, 2024, 39(2): 19-27. doi: 10.12187/2024.02.003
Citation: ZHANG Zhiping, SONG Yangyang, WANG Qiuling, et al. Research on extraction process of carotenoids from yeasts and algae based on ionic liquid[J]. Journal of Light Industry, 2024, 39(2): 19-27. doi: 10.12187/2024.02.003
shu

基于离子液体的菌藻类胡萝卜素提取工艺研究

    作者简介:张志平(1981-),男,河南省安阳县人,郑州轻工业大学副教授,博士,主要研究方向为生物质资源化利用。E-mail:zzp@zzuli.edu.cn
  • 1. 郑州轻工业大学 食品与生物工程学院, 河南 郑州 450001;
  • 2. 河南中烟工业有限责任公司 技术中心, 河南 郑州 450003;
  • 3. 农业农村部成都沼气科学研究所, 四川 成都 610042;
  • 4. 山东省农业科学研究院, 山东 济南 250100
  • 收稿日期: 2023-10-24
  • 录用日期: 2024-02-24
基金项目:  河南省科技攻关项目(212102310077)中原科技创新领军人才项目(224200510017)

摘要: 以含有粘红酵母和小球藻的菌藻泥为原料,通过单因素试验和响应面试验对菌藻类胡萝卜素提取工艺进行优化,并考查菌藻类胡萝卜素的体外抗氧化活性。结果表明:菌藻破壁的最优离子液体为1-丁基-3-甲基咪唑氯化物(BMIMCl),菌藻类胡萝卜素的最佳提取工艺为离子液体浓度1 mol/L、预处理温度53 ℃和预处理时间57 min,在该条件下,菌藻类胡萝卜素的提取量为1.311 mg/g;当质量浓度为30 μg/mL时,菌藻类胡萝卜素对DPPH自由基、·OH自由基和ABTS+自由基的清除率分别为82.3 %、37.6 %、和86.8 %,还原力为0.289,表现出较好的抗氧化活性。因此,经BMIMCl破壁处理后,从菌藻泥中提取的类胡萝卜素含量更高,抗氧化活性也较好。

English Abstract

参考文献 (27) 相关文章 (4)

目录

/

返回文章

网站版权 © 轻工学报编辑部

地址：河南省郑州市科学大道136号邮编：450001

本系统由北京仁和汇智信息技术有限公司开发 技术支持： info@rhhz.net